S SeriesPart Numbering/Specifying Guidelines INTRODUCTION The LEMO Series Connector program offers considerable versatility and flexibility through the use of a variety of options and accessories. The part numbering system is both complex and powerful as a means of accurately describing a single precise set of connector characteristics. HOW TO SPECIFY: Specifying a LEMO S Series connector can be accomplished by following the checklist below. 1. SHELL CONFIGURATION For S Series Plugs see page 48. PLUG *[FFA|[ 1S |[3][06][C|[L][A]LC][60]: 2 : 2. SHELL SIZES & SERIES For S Series Plug Shell dimensions see pages 50-53. 3. INSERT TYPE 1 Single Contact, page 64 2 Coaxial 50 or 75 ohm, page 65 3 Multicontact, pages 67-69 6 Triaxial 50 or 75 ohm, page 66 7 Mixed high voltage & signal contacts, pages 70-71 8 Mixed coaxial & signal contacts, pages 72-75 4. NUMBER OF CONTACTS All currently available insert styles are illustrated on pages 64-75 (see above insert type). With multicontact inserts, the number in this position refers to the total number of contacts. 10. VARIANT Z Signifies a Strain Relief Backnut. See page 94 for ordering strain reliefs. 9. COLLET SIZE Specify the correct collet size from the charts on pages 78-83. The chart indicates the maximum and minimum cable @ suitable for each size collet. 8. COLLET TYPE See pages 78-83. C Shielded Collet K Oversized Collet 7. CONTACT TYPES Contact types are as follows: A Male, solder D Male, printed circuit 6. INSERT MATERIAL L PEEK (multicontact)! N PBTP (special request)! T PTFE (coax, high voltage) 5. OUTERSHELL MATERIAL Outershell materials are as follows: C Brass with chrome matte surface treatment & finish N Brass with nickel matte surface treatment & finish (on request) Other materials available on special request: L Aluminum S Stainless Steel T Stainless Steel with stainless latch sleeve, collet and midpieces X Avional G PEEK K Brass with black chrome plating *FFA.1S.306.CLAC60Z Straight Plug with cable collet. 1S Series. multicontact (6 pins). chrome plated brass shell, PEEK insert, male solder contacts with standard collet size 62 and backnut to accommodate a cable strain relief. In January 1992 PEEK replaced PBTP as the standard S series insert material for multicontact connectors in sizes 0-2 only. PBTP is available upon special request. L LEM = inc ELECTRONIC CONNECTORS 46 PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesPart Numbering/Specifying Guidelines RECEPTACLE TERA|(1S |[3|io6 ile LIE). ih i 1. SHELL CONFIGURATION 10. VARIANT (for cable- For S Series Receptacles terminated receptacles) see page 48. Z Signifies a Strain Relief Backnut. See page 94 for ordering strain reliefs. 9. VARIANT-COLLET SIZE 2. SHELL SIZES & SERIES (for cable terminated For S Series Receptacle Shell receptacles) Specify the correct dimensions see pages 54-61. collet size from the charts on pages 78-83. The chart indicates the maximum and minimum cable @ suitable 3. INSERT TYPE for each size collet. 1 Single Contact, page 64 2 Coaxial 50 or 75 ohm, page 65 8. VARIANTCOLLET TYPE 3 Multicontact, pages 67-69 (for cable-terminated 6 Triaxial 50 or 75 ohm, page 66 receptacles) See pages 78-83. 7 Mixed high voltage & signal C Shielded Collet contacts, pages 70-71 K Oversized Collet 8 Mixed coaxial & signal contacts, pages 72-75 7. CONTACT TYPES Contact types are as follows: 4, NUMBER OF CONTACTS L Female, solder All currently available insert N Female, printed circuit styles are illustrated on pages 64-75. With multicontact 6. INSERT MATERIAL inserts, the number in this L PEEK (multicontact)' position refers to the total N PBTP (special request) number of contacts. 5. OUTERSHELL MATERIAL Outershell materials are as follows: C Brass with chrome matte surface treatment & finish (standard) N Brass with nickel matte surface treatment & finish (on request) Other materials available on special request: L Aluminum S Stainless Steel T Stainless Steel with stainless latch sleeve, collet and midpieces X Avional G PEEK K Brass with black chrome plating ERA.1S.306.CLL Fixed Receptacle, 1S Series, multicontact (6 pins), chrome plated brass shell. valox insert and female solder contacts. In January 1992 PEEK replaced PBTP as the standard S Series insert material for multicontact connectors in sizes 0-2 only. PBTP is available upon special request. Lh LEI | gc ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 47S SeriesShell Configurations Straight and elbow plugs Fixed Receptacles Free and Fixed Receptacles with Cable Collets a ~ | bp icuk ; PCA, PCP PCA Vacuum Sealed Receptacles Fixed receptacles > Hl 1 Hl | r F ixed coupler >| SWH HGP Model description CFF Bridge plug with two non latching plugs CRD Bridge plug with two non latching plugs and one receptacle for measurement CRF Bridge plug with two non latching plugs and one monitoring receptacle EBC Fixed receptacle with square flange, visible shell (screw fixing) EBD Fixed receptacle with square flange (screw fixing) EBS Fixed receptacle with round flange (screw fixing) ECP Fixed receptacle with two round fixing nuts EHP Fixed receptacle, visible shell EPL Elbow receptacle (90) for printed circuit ERA Fixed receptacle ERC Fixed receptacle with slot on flange ERD Fixed receptacle (back panel mounting) ERM Fixed receptacle with microswitch ERN Fixed receptacle with tag ERT Fixed receptacle force or adhesive fit Plug/Receptacle f Combinations rl a 7 Swiss la felis: ww CFF, CRF, CRD EWB Fixed receptacle, nut fixing, with two FAA FBC FEF FFA FFA FFA FFB FFP FLA FRT FTA FTR FTY flats on flange (waterproof) Straight plug non latching, nut fixing Straight plug with round flange and cable collet (screw fixing) Straight coupler with two plugs Straight plug with cable collet Straight plug with cable collet and oversized collet Straight plug with cable collet and collet nut for fixing a strain relief Straight plug with cable collet and safety nut Straight plug with inner anti-rotating device and cable collet Elbow plug (90) with cable collet Straight plug with resistor Tplug with two receptacles in line Elbow plug (90) with receptacle Straight plug with two parallel receptacles I Hf TI a~ Ett PUETETTE Le] FZP Straight plug for remote handling with cable collet HGP Fixed receptacle, nut fixing, (watertight) HGW Fixed receptacle, nut fixing, with back washer, (waterproof) Free receptacle with cable collet Free receptacle with cable collet and oversized collet Free receptacle with cable collet and collet nut for fixing a strain relief Free receptacle with inner anti-rotating device and cable collet Fixed receptacle with cable collet, nut fixing Fixed receptacle with inner anti-rotating device and cable collet Free receptacle for remote handling with cable collet RMA Free coupler RAD Fixed coupler, nut fixing SWH Fixed coupler, nut fixing, (waterproof) PCA PCA PCA PCP PSA PSP PzP 48 "L LEM TEST RONG CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesTable of Shells & Sizes Mixed High Mixed Coax & Low & Low Single Contact Coaxial Multicontact High Voltage Triaxial Voltage Voltage | Shell | Series i Series I Series | Series I[ Series || Series || Series [ style _|[oojos|1s[2s/ss|4sjss|[os|1s]es|3s|4s|5s]os] 18 |2s]38]/48|5s]6s][os| 1s 2s/3S]4s]|0s]18]28]38]4s][35]48|5s|[3S]48|5s\6s| CFF e e\e CRD e CRF e ele EBC e\ele e\ele e elele e eliele e ee e EBD e e e e EBS e e e e e ECP elelele elelele @e\elele elelele e e EHP ele e el\e e ele e e|e e e\e e e e EPL e e ele ERA @Cleleleleielelele/eiel/el/eleieieieiel/el/eleieielelelieieielelelelei/elel|eliele ERC elele e\e e\e el\e ele ERD @elelelele elelelele eleleleie @elelelelellel/elel/elelele e\e ERM e|\e ele ERN elelele elelele e\elele elelele ERT e e e e e e EWB eje|\e e elele e elele ele elel\e ell\el\ele FAA ejelelelele elelelele eleleleleleleleielele elelele elelelelielele FBC e FEF e FFA Clelel/elelel/ele/e/eielei/eliei/el/eie/eiele Clele\eieile/el/elel/elelea FFA e elejelele e|e ele FFA2) eleljelel/elelelielelelele ejelelele elelelelelele ele FFB elelelele e\elelele el\el\eleleo e\eleicele ele ele FFP ele\el\ele el\le elelelelele FLA elelelelelelelelelelele elelelelelele elelele elelelielele FRT e e FIA e\ele e\e e\e ele FTIR e e e\e e\e FTY e FZP elelelele ejelelele elelelel/ele elelele clelelele/elelele(e ie HGP elelelele ejelelele elelelele elelele ejelele HGW e e e e e PCA C\elelelelelellel/eielel/eleliel/ei/ejelel/el/eliei/ej/eiel/elelelelei(elel/eleleielele PCA" e elelelele ie el|e PCA?) elelel/elele e\eielele @e\elel\e|/e elelele eleleleleliele e\e PCP ejeleljele e\e e\je e\e PSA Clelelelelelellel/el/elelelelel/eleleieieieleieleielelelel/e/el/elieieieleielele PSP e;elelele el\e elelelele PZP elele elele elele @\lele elele e e RAD elele e ejelelele elelel|elele ele elelele RMA elele e elel/ele\e e\elelelele el\e elelele SWH e ele el\e\ele|e e\eleielelelo e e ele Models with oversized collet The oversized collets for the FFA and PCA models allow the use of a cable having a sheath diameter equal to the one used on the following series. Models with collet nut for fixing a strain relief To order models with collet nut for fixing a strain relief, add a 2 in the Variant position of the part number. The strain reliefs are available in nine colors and can accommodate different cable ODs. They are to be ordered separately as indicated in the Accessories section. All models fitted with a cable collet are also available with collet nut for fixing a cable relief. Vacuum Sealed Models The HGP, EWB, HGW fixed receptacles and SWH coupler enables the device on which they are fitted to reach a protection index of IP66 as per IEC 529 (not connected). They are fully compatible with all non-watertight models of the same series and can be widely used for outdoor TV cameras, man-portable radios, in armored vehicles, on ship installations and in the aircraft industry. The technical solutions adopted allow the vacuum sealed models to perform better than the requirements of the MIL-STD-1344A standard method 1008. To seal the watertight and vacuumtight models, LEMO uses an epoxy resin. Maximum working temperature is 80C on these models. 1) Oversized collet 2) Collet nut for strain relief PIC ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 * telefax 707/578-0869 49S SeriesPlugs FFA Straight Plug with Cable Collet Series Dimensions (mm) A|tc|]teti{ms, 00 6.4] 3.2] 26.0) 18.0) 4.5 os 9.0; 4.2] 34.5] 24.5] 6.5 1S |} 12.0] 6.2] 42.5) 31.5] 8.5 28 || 14.8} 85) 52.0! 40.0 | 11.0 3S || 17.8 | 10.5 | 61.0! 46.0 | 13.9 4S || 24.8 | 13.2 | 77.0] 59.0 | 18.9 5S || 35.1 | 22.2 |103.0] 78.0 | 28.9 FFA Straight Plug with Cable Collet and Backnut to accommodate a Strain Relief 90 Series Dimensions (mm) Aitc]t|m {| s2 00 || 64] 3.4/| 34.0] 260] 6 os 9.0] 4.2 | 36.5 | 26.5 7 1S || 12.0] 6.2} 45.0]/340] 9 28 || 148) 85 | 545/425] 12 3S || 17.8 | 10.5 | 64.0 | 49.0] 14 4S || 24.8 | 13.3 | 80.5 | 62.5] 20 FFA Straight Plug with Oversized Collet Nut Series Dimensions (mm) A|Bi[cft{i{m {st {se 00 || 6.4] 8.0| 4.2] 34.0] 26.0] 7.0] 65 0s 9.0|10.0/ 62] 45.5) 355| 90] 85 1S || 12.0] 13.0] 85] 57.0] 46.0] 12.0 | 11.0 2S || 14.8 | 18.0 | 10.5 | 67.0] 55.0] 14.0 | 13.9 3S || 17.8 | 21.0 | 13.2 | 85.0] 70.0] 19.0 | 18.9 4S || 24.8 | 31.8 | 22.0 |107.0/ 99.0] 28.5 | 28.9 5S || 35.1 | 41.8 | 30.5 | 138.0] 112.5] 37.5 | 37.9 L LEI 028 PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (6366) (707) 578-8811 teleftax 707/578-0869S SeriesPlugs-continued FFB Straight Plug with Cable Collet and Safety Nut PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 Series! Dimensions (mm) Alc | | m | se os 9.0] 4.2]|36.8| 268] 65 1S [1120] 6.2/ 4501340] 85 2S || 14.8] 8.5 | 55.5 | 43.5 | 11.0 3S || 17.8 | 10.5 | 65.0 | 50.0 | 13.9 4S || 24.8 | 13.2 | 81.5 | 61.5 | 18.9 FFP Straight Plug with Inner Anti- Rotating Device and Cable Collet Series Dimensions (mm) 21 L_[ M | s2 oS || 9.0 34.5 | 245] 6.5 1S || 12.0] 6.2|425/315| 85 28 || 14.8] 8.5 | 52.0 | 40.0] 11.0 3S || 17.8 | 10.5 | 61.0 | 46.0 | 13.9 4S || 24.8 | 13.2 | 77.0 | 59.0 | 18.9 a | FZP Straight Plug for Remote Handling with Cable Collet : Dimensions (mm) Series A | = | mM | N | s2 3 53 1S || 16 42.5] 31.5 | 15.0| 8.5 res ee 28 || 24 | 85] 52.0] 40.0 | 21.0] 11.0] 18 be a 3S || 24 | 10.5] 61.0] 46.0 | 24.0/ 13.9] 18 a 4S || 35 | 13.2! 77.0] 59.0 | 300/189] 28 \ | f 5S || 43 | 22.0 |103.0] 78.0 | 44.0 | 28.9] 35 g i) 6S || 60 | 30.5 |106.0} 81.0 | 44.0 | 37.9] 50 82 n $3 Lh LE inc ~ ELECTRONIC CONNECTORSS SeriesPlUgs-continued FLA Elbow Plug (90) with Cable Collet : Dimensions (mm) S , ene Ajlat{[c]uH {et |{M | si | s2 00 9 3.2/16.0)176] 96) - 5.0 0s 13 13 4.2 | 24.5 | 23.0 | 13.0 8 6.5 18 16 16 6.2 | 28.5 | 26.5] 15.5] 10 8.5 25 20 20 8.5 | 37.0 | 31.0) 19.0) 13 | 11.0 3S - 21 | 10.5 | 44.0 | 38.5 | 23.5] 15 | 13.9 4S - 28 | 13.0 | 56.0 | 49.0 | 31.0] 20 | 18.9 5S - 37 | 22.0 | 76.5 | 65.0 | 40.0 | 30 | 28.9 6S - 48 | 30.5 | 94.0 | 81.0 | 56.0} 40 | 37.9 FAA Panel Mounted Plug Non-Latching s eal Dimensions (mm) TAL Bloe [ETL [ul|weli(ele[m|s|s 00 8 |10.3|M7x05| 20] - |i55] - | - | - | go] 63] 9 os 10 | 12.5 | M9x0.6 | 2.0 | 18.5 | 18.0 | 18.5 | 26.3] 200/112] 82) 11 18 14 | 16.0 |M12x1.0) 2.5 | 22.5 | 21.7 | 22.5 | 33.5 | 24.2)125/105] 14 2s 18 | 19.5 |M15x1.0) 4.0 | 25.0 | 25.3 | 26.2 | 43.0 | 27.7 | 13.8 | 13.5 | 17 3S 22 | 25.2 |M18x1.0] 4.0 | 31.0 | 29.0 | 31.0 | 49.0 | 34.0)17.0) - 22 4S 28 | 32.0 |M25x1.0) 2.5 | 35.5) 39.0/365) - |40.3/205|] - 30 5S 40 | 40.0 |M35x1.0] 2.5 | 45.0) - - - - | 28.0 | 33.5] 40 6S 54 | 54.0 |M48x1.5) 25 | 45.0] - _ - - |28.0]) - 54 L = Multicontact Emaxi L1 = Single contact - L2 = Coaxial contact L3 = High voltage contact L4 = Triaxial contact * Dimension L may vary depending on contact configuration. Refer to contact configuration above. For panel cutouts please see table on page 85. Lh LEME pc ELECTRONIC CONNECTORS 52 PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesBridge Plug CFF Bridge Plug with Two Non-Latching Plugs Dimensions (mm) A[B]H{|LI[MIN os |[13.5] 14 | 27.5 | 36.5 | 27.2 | 22.5 18 |[15.0| 20 | 35.0 | 42.0 | 31.0 | 22.0 Series| (Ssims Gb aye: CRF Bridge Plug with Two Non- Latching Piugs and One Monitoring Receptacle -A= law Series Dimensions (mm) = |() AjatH{t{[mIn WF OS || 13.5] 14 | 27.5 | 37.2 | 27.2) 22 1S 15.0] 20 | 35.0 | 42.0 | 31.0] 22 CRD Bridge Plug with Two Non-Latching Plugs and One Receptacle for Measurement /SSIMS Gb Ck Dimensions (mm) A[Bic{[H|{[tI[mMIN [is | 15 | 22 | 4 [| 35 | 40 | 31 [ 22 | Series| Bridge plugs in the S Series are only available in coax and triax versions. For multicontact versions please see pages 13-15 in the B Series. o he LRM ic ELECTRONIC CONNECTORS PO, Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) * (707) 578-8811 telefax 707/578-0869 53S SeriesReceptacles above. For panel cutouts please see table on page 85. * Dimension L may vary depending on the contact configuration. Refer to contact configuration rr wo ui it wou wt a above. Coaxial contact High voltage contact Triaxial contact Mixed high voltage and signal Mixed coaxial and signal For panel cutouts please see table on page 85. * Dimension L may vary depending on the contact configuration. ERD Fixed Receptacle (Back Panel Mounting) : Dimensions (mm) eries| A |B e [| E L [u | t2][u{[tai[ om {| si | s2] s3 os || 12 | 12.5 | mox0.6] 5.5 |17.5]185/17.4]246]188/ 25 | 82; 10 | 11 1s || 16 | 16.0 |M12x1.0| 6.0 | 21.5 | 21.4 | 20.0 | 32.0 | 23.2] 3.2 1105] 13 | 14 2s || 20 | 19.5 |M15x1.0] 6.0 | 24.0 | 25.7 | 24.5 | 41.4 | 26.0] 3.8 113.5] 17 | 17 3s || 24 | 25.2 |M18x1.0] 7.5 | 27.2 | 29.8 | 28.2/52.0/31.8] 45 |165] 20 | 22 L Multicontact Li = Single contact Refer to contact configuration ERA Straight Receptacle (Front Panel Mounting) eries Dimensions (mm) A{l[B] e [eETtet{u]ftw]is{[t4] is {is |] m | st] ss 00 8 |10.3)M7x0.5/ 55] - [15.1] - - - - - 1.0] 63 9 os 10 | 12.5 | M9x0.6| 7.0|17.5 | 18.5 | 17.4] 246/188) - - 1.2] 82] 11 1S 14 | 16.0 |M12x1.0; 7.5 | 21.5 | 21.4 | 20.0 | 32.0 | 23.2} - - 15 (10.5] 14 2s 18 | 19.5 1M15x1.0] 8.5 | 24.0 | 25.7 | 24.5 | 41.4 | 26.0) - - 1.8 /13.5] 17 3S 22 | 25.2 |M18x1.0] 11.5 | 27.2 | 29.8 | 28.2 | 52.0 | 31.8 | 32.0 | 29.5 | 2.0 | 16.5] 22 4S 28 | 32.0 |M25x1.0| 12.0 | 32.3 | 36.0 | 34.6 | 56.7 | 38.5 | 39.3 | 34.0] 25 | 23.5] 30 5S 40 | 40.0 |M35x1.0] 15.5 | 44.9|53.2]}440] - - |51.3]43.2] 3.0 | 33.5] 40 6S 54 | 54.0 |M48x1.5| 16.0 | 44.0 - 44.5 - - - 44.5)] 3.5 | 45.5] 54 L = Multicontact Lt = Single contact L2 = Coaxial contact L3 = High voltage contact L4 = Triaxial contact L5 = Mixed high voltage and signal L6 = Mixed coaxial and signal 54 L LEME 4 "IC ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesReceptacles-continued ERN Fixed Receptacle with Grounding Tab *Dimension L may vary depending on contact configuration. Refer to contact configuration above. For panel cutouts please see table on page 85. Series Dimensions (mm) Asef ius os 10 | 12.5 | M9x0.6 24.6 | 1.2 8.2 1s 14 | 16.0) M12x1 7.5 | 32.0) 1.5 |10.5| 14 3S 22 | 25.2 | M18x1 | 11.5] 31.8] 2.0 |165] 22 EBD For panel cutouts please see table on page 85. Fixed Receptacle with Square Flange Mounting Series| Dimensions (mm) A{sB{[c]Hi{_ tf[ulef]u]ulso L Li L2 L3 Multicontact Single contact Coaxial contact High voltage contact = L4_ = Triaxial contact *Dimension L may vary depending on contact configuration. Refer to contact configuration above. For panel cutouts please see table on page 85. [ 2s |] 22 | 15 | 32 [15.6] 24.1 | 25.7] 245] 41.4] 26 | EHP Fixed Receptacle, Visible Shell Series! Dimensions (mm) Z| A{Bi]e [eE|jfutl ui fe [is Te Ps is | mM | 83 0s 10 | 12.5 | M9x0.6 | 2.5 | 22.0 / 20.6 | 20.5 | 25 12.56] 11 1s 14 | 16.0 |M12x1.0) 2.0 | 21.5 | 21.4 | 20.0] 32 | 23.2 - - 11.0] 14 3S 22 | 25.2 |M18x1.0} 4.5 | 27.2 | 29.8 | 28.2) 52 | 31.8; 32 | 29.5] 18.7] 22 L = Multicontact i L1 = Single contact : L2 = Coaxial contact < L3 = High voltage contact & L4 = Triaxial contact t L5 = Mixed high voltage and signal L6 = Mixed coaxial and signal "L LEM ELECTRONIC CONNECTORS 7 mmCe PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 95S Series Receptaclescontinued EBS Fixed Receptacle with Round Flange Mounting Series Dimensions (mm) A/lBic{TuH{[tcfululululo L TT AWD Hugh dt Multicontact Single contact Coaxial contact High voltage contact Triaxial contact * Dimension L may vary depending on contact configuration. Refer to contact configuration above. For panel cutouts please see table on page 85. [1s || 22 | 11 [| 25 | 124] 21.5] 21.4] 20 | 32 [23.2] 1.5 | ERT Fixed ReceptacleForce or Adhesive Fit xn. . . = . Dimension L may vary depending on contact configuration. Refer to contact configuration above. For panel cutouts please see table on page 85. Series Dimensions (mm) A[BilT[E;Te{[ufulif[u]o 00 8 | 6.98] 3.5 - | 15.0} 15 = - 1.0 1S 14 411.98} 3.5 | 21.5) 21.4) 20 | 32 | 23.2] 1.5 *L maxi = L Muiticontact L1 Single contact kK - 0B x MME cr Nn uaenu dl bw "ne Fe Coaxial contact High voltage contact Triaxial contact * Dimension L may vary depending on the contact configuration. Refer to contact configuration above. For panel cutouts please see table on page 85. EBC Fixed Receptacle with Square Flange, Visible Shell Series Dimensions (mm) A|/Bi[c]TH|{ te fulfuU{ufififie|mI{n 1s 18 | 11.5] 3.2 | 12.7 | 21.5 | 21.4 | 20.0 | 32.0 | 23.2| - - |165] 28 2S 22 | 15.0) 3.2 | 15.5 | 24.0 | 25.7 | 24.5 | 41.4 | 26.0 - - 18.5 | 4.4 38 25 | 18.0] 3.2 | 18.0 | 27.2 | 29.8 | 28.2 | 52.0 | 31.8 | 32.0 | 29.5 | 23.5 | 3.0 5S 45 | 40.0] 4.3 | 36.8] 44.9]53.2/440) - - |51.3 | 43.2] 15.0] 4.0 L = Multicontact L1 = Single contact L2 = Coaxial contact L3 = High voltage contact L4 = Triaxial contact L5 = Mixed high voltage and signal L6 = Mixed coaxial and signal 56 L LEM " ELECTRONIC C ONNE "ine CTORS PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S Series Receptacles-continued ERM Fixed Receptacle with Microswitch ISeries| Dimensions (mm) A[B|e [E[t[{[mM|{[s1]83 os 10 | 12.5} M9x0.6| 7.0} 35 | 1.2 | 82] 11 1S 14 | 16.0 |M12x1.0) 7.5] 38 | 1.5 | 10.5] 14 For panel cutouts please see table on page 85. M Fi BA E maxi 1 ERC Fixed Receptacle with Slotted Flange Dimensions (mm) Alsplefel]ri{itI{t os 10 | 12.5 | M9x0.6 | 7.0 | 2.0 | 17.5 | 18.8 18 14 | 16.0 |M12x1.0) 7.5 | 2.5 | 21.5 | 23.2 Series} L L4 Multicontact Triaxial contact * i... . + Dimension L may vary depending on the contact configuration. Refer to contact configuration above. For pane! cutouts please see table on page 85. Elbow Plug (90) for Printed Circuit Series Dimensions (mm) A;Tc{[ad[afH]t{[ute[mI[n Los ies[ 1 [5 [5 [12] 9 [za7las| 9 | See page 25 for alternative shell design. L LEME. 26 ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707} 578-8811 telefax 707/578-0869 57S SeriesReceptacles-continued PCA Free Receptacle with Cable Collet Dimensions (mm) A[c]t]|se 00 6.4) 3.2| 24.5] 4.5 os 8.9] 4.2) 33.5] 6.5 me L ee 1S |} 11.9] 62] 40.5] 85 Series I = mes 28 || 14.8] 8.5 | 50.0] 11.0 te ae eee j 38 ST att ree 17.8 | 10.5 | 59.0] 13.9 * ae a 8 4S || 24.8 | 13.3 | 75.0| 19.0 gut aE i 5S || 34.7 | 22.2 | 99.0] 29.0 $2 PCA Free Receptacie with Cabte Collet and Backnut to accommodate a Strain Relief Dimensions (mm) Al[c [et | se 00 64] 3.4] 32.5 6 os 8.9 | 4.2 | 35.0 7 iS |} 11.9] 62 | 43.0 9 2S || 14.8) 8.5)525) 12 3S || 17.8 | 10.5 | 62.0) 14 4S || 24.8 | 13.3 | 79.5 | 20 Series bat FA. mt PCA Free Receptacle with Oversized Collet Nut Series Dimensions (mm) I B | c {ce ist | se 00 8.0} 4.2) 35.0) 7.0] 6.5 OS || 10.0} 62] 44.5) 9.0] 8.5 1S || 13.0] 8.5 | 56.5] 12.0 | 11.0 ri 2S || 18.0 | 10.5 | 65.0] 14.0 | 13.9 Ao : 3S || 21.0 | 13.2 | 81.0] 19.0 | 18.9 2S pet 4S || 31.8 | 22.0 ]106.5| 28.5 | 28.9 1 io = 5S || 41.8 | 30.5 |131.5] 37.5 | 37.9 L LEME ag 58 PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S Series Receptacles-continuea PCP Free Receptacle with Inner Anti-Rotating Device and Cable Collet series Dimensions (mm) A[c]e | s2 oS || 89] 42/335] 65 2S || 14.8| 8.5 | 50.0 | 11.0 3S || 17.8 | 10.5 | 59.0 | 13.9 4S || 24.8 | 13.2 | 75.0 | 18.9 PSA Straight Receptacle with Cable Collet Series Dimensions (mm) A{Bli[c] e | E[t]|m]|si]s2]s3 00 8 | 10.3 | 32.0} M7x0.5| 55|245/ 1.0] 63] 50] 9 oS || 10 {12.5} 4.2) M9x0.6| 7.0] 33.5] 1.2 | 82] 65) 11 1S || 14 | 16.0] 6.2] M12x1 |] 7.5] 40.5] 1.5 |10.5| 8.5] 14 2S || 18 |19.5| 85] M15x1 | 85] 50.0] 1.8 |13.5]11.0| 17 3S || 22 | 25.2 | 10.5 | M18x1 | 11.5) 59.0) 2.0 | 16.5] 14.0] 22 ' 4S || 28 | 32.0 | 13.2 | M25x1 | 12.0] 75.0] 2.5 | 23.5| 189] 30 5S || 40 | 40.0 | 22.0 | M35x1 | 15.5] 99.0] 30 | - | 289] - 6S || 54 | 54.0 | 30.5 |M48x1.5| 16.0 |102.0/) 35 | - |37.9) - For panel cutouts please see table on page 85. PSP Fixed Receptacle with Inner Anti-Rotating Device and Cable Coilet Series Dimensions (mm) A|spB{i[c]e [e{[utI[{mI]{si [se] s3 oS |} 10 {12.5} 4.2) M9x0.6] 7.0/33.5] 1.2] 82] 65] 11 1S || 14 | 16.0] 6.2 |Mi2x1.0] 7.5] 40.51/15 |105] 85] 14 2S || 18 | 19.5] 8.5 |M15x1.0] 8.5 | 50.0 | 1.8 | 13.5] 11.0] 17 3S |} 22 | 25.2 | 10.5 |M18x1.0| 11.5 | 59.0 | 2.0 | 16.5] 14.0 | 22 4S || 28 | 32.0 | 13.2 |M25x1.0/ 12.0 | 75.0 | 2.5 | 23.5|18.9| 30 For panel cutouts please see table on page 85. L LEME ELECTRONIC CONNECT 1G ORS PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 299S SeriesVacuum Sealed Receptacles For certain applications, LEMO has vacuum sealed These models are intermatable with other S Series receptacles which provide the unit on which they are connectors in this catalog and are indicated by adding a mounted to have protection per standard IP66, IEC529 (with- Vv to the end of the part number. Refer to pages 46-47 out power). The technical solutions adopted offer for part number specifying. performances which are better than those specified in MIL- STD-1344A, method 1008. To seal these connectors LEMO uses an epoxy resin. The maximum leakage rate of these connectors is 1 x 10 Maximum working temperature is 80 C on these models. torrliters/sec. HGP Fixed Receptacie, Nut Fixing Dimensions (mm) AlBpB[e [E[t{[ufuwflululiom{[s os || 18 | 16.0 | M12x1 | 11.5 | 22.0 | 20.6 | 20.5 | 24.7| 21.5] 4.0 | 11 1S || 20 | 19.5 | M14x1 | 15.5 | 25.5 | 25.5 | 24.5 | 31.4 | 26.5 | 4.0 | 16 28 || 20 | 21.8] Miex1 | 17.3 | 28.0 | 26.5 | 29.5 | 41.2 | 30.0] 4.0 | 20 3S || 28 | 25.2 | M2ox1 | 19.0 | 35.5 | 34.6 | 33.0 | 58.7 | 34.5] 6.0 | 22 eries 4S 34 | 32.0 | M25x1 | 22.5) 41.0]; - |405] - | 41.0} 65 | 30 5S 45 | 35.0 | M35x1 | 28.0 | 54.5 - 54.0 - - 7.5 40 L = Multicontact dimension L1 = Single contact dimension L2 = Coaxial dimension L3 = High voltage dimension L4 = Triaxial dimension el For panel cutouts please see table on page 85. EWB Fixed Receptacle, Nut Fixing with Two Flats on Flange Seri Dimensions (mm) erie A;lTB[e [E/[uti{uftei{is]{u[ om | sa] sa 0s 13 | 12.5 |M12x1.0) 10 | 22.0 | 20.6 | 20.5 | 24.7 | 21.5] 35 | 11 9 1s 20 | 19.5 |IM14x1.0}) 17 | 25.5 | 25.5 | 24.5 | 31.4 | 26.5! 40 | 16 | 16 28 20 | 21.8 |M16x1.0| 19 | 28.0 | 26.5 | 29.5 | 41.2 | 30.0} 4.0 | 20 16 L = Multicontact dimension rT 4 L1 = Single contact dimension j i MT L2 = Coaxial dimension oO | L3 = High voltage dimension a i =| : Nil | L4 = Triaxial dimension | 1 ! ut WU * Dimension L may vary depending on contact configuration. Refer to contact configuration yy at right. E maxi For panel cutouts please see table on page 85. L LEME ix ELECTRONIC CONNECTORS 6 O PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesSealed Panel Mounted Receptacles =continued HGW Fixed Receptacle, Nut Fixing, with Back Washer Dimensions (mm) A[B] e [eE{;Tutftuf]wufufiu] ou [ss | os || 10 [125|Mox0.6] 2 | 22 | 20.6] 205] 24.7] 215] 1.2] 11 | Series| Multicontact dimension Single contact dimension L2 = Coaxial dimension L3 = High voltage dimension x L4 = Triaxial dimension & * Dimension L may vary depending on the contact configuration. Refer to contact configuration above. =| wEMAx! For panel cutouts please see table on page 85. | is ae Het Ni 1 | PROS aol Single Contact poed,- SWH Fixed Coupler, Nut Fixing Coaxial Types ~ Do 8| 8 2| 3 =| $ 5 Dimensions (mm) : = Oo] | a] 2 }, Multicontact Series) @| S| F] 2] =f a] B] e JEL v8 |_s3 oS jj@l;e/el;e 14 | 13.8 M10x0.75; 17 34 9 12 1S e\;@e\/e/\e 17 | 16.0 |M12x1.0] 28 39 2.5 |10.5| 14 2S ||} @|e e 20 | 21.8 |M16x1.0} 25 44 4 15 20 : 3S e\|e e;\e 25 | 27.0 |M20x1.0| 30 53 4 18.5} 24 Multicontact 6 4s e e 34 | 32.0 |M25x1.0] 50 65 4 | 23.5] 30 5S e 45 | 45.0 |M35x1.0/ 58 80 5 |33.5] - 6S e 58 | 54.0 |M48x1.5| 55 81 6 |45.5) - High Voltage For panel cutouts please see table on page 85. L LEM ..i26 ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 6 1S SeriesCouplers High Voltage RMA lo Free Coupler E Types L j Dimensions (mm) (~ = Series A | L | u () Single Contact ((O) t 00 || @ e\e 6.4 | 220] - os el\ele 8.9 | 25.0 - 1s @e\el|e 11.9) 285) - Coaxial ) 2s llelelelele|l 1481315) 54 Net 3S jlelele 17.8 | 38.5 | 60 1 4S ele 24.8 | 46.5 | 70 fe * 58 || [ele 34.7[ 60.5] - a4 ! ], Multicontact LOO) wo. os Triaxial Us) (OWN High Voltage ramay = = ae Lo M a $3 1M 7 ; e | r ) Single Contact 6) EY (Cy RAD ) Coaxial Fixed Coupler - Nut Fixing Types 1 1 ns B & Multicontact O65 _ 2 = 2 'y 3 2 2 : 8 s|= Dimensions (mm) ; ; Series||5|S/Sl=/2|| A | B [| e [| E [ t [mM [si |[s3 3 1 1 3 00 |je\e 8 | 10.3 | M7x0.5 | 5.5] 22.0] 1.0 6.3 9 ' s). Multicontact os |jelelelele|| to | 125|moxoe| 70/250; 14) - [1 5 3 1S ||el/@e/el\ele 14 | 16.0 |M10x1.0) 7.5] 28.5] 1.7 110.5] 14 2s ele e 18 | 19.5 {M15x1.0} 85/315] 1.8 - 17 - wiavel Cs: 3S lle[ele! [el] 22 | 25.2 [M1ex1.0/ 115/385] 20] - | 22 taxa Lee) 4S ele 28 | 32.0 [M25x1.0| 12.0] 46.5| 25 | - | 30 5S e 40 | 40.0 |M35x1.0] 15.5 | 60.5 | 3.0 - ~ For panel cutouts please see table on page 85. 62 L LEME me ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesPlug/Receptacle Combinations FTY Straight Plug with Two Parallel Receptacles Series! Dimensions (mm) A|Bi]H{[tI[M [os |[ 15 [ 12 | 24 [378 [27.8 | FTR Elbow Plug (90) with Receptacle Dimensions (mm) AlTH] Ife 00 9 /17.5] 9.5] 18.5 0S 13 | 23.0 | 13.0 | 24.0 18 16 | 26.5 | 15.5 | 28.5 38 21 | 38.5 | 23.5 | 41.5 4S 28 | 49.0 | 31.0 | 54.0 Series FTA T-Plug with Two In-Line Receptacles Dimensions (mm) ATH{ It ]L 00 9/175] 9.5] 30 0S 13 | 23.0} 13.0] 38 1S 16 | 265/165] 45 38 21 | 38.5 |} 23.5] 64 4S 28 | 49.0 | 31.0} 83 Series FRT Straight Plug a ce Em with Resistor | . * eries) 4 ; A {Lt S 1S ][ 11.9] 45.5 t 4 4s (24.8 [106.0 _ ~ *.. : 2 Dimensions (mm) Lh LEME pc ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) * (707) 578-8811 telefax 707/578-0869 63S SeriesInsertsSingle Contact Specifications are based on PTFE insulators. For other insulators consult LEMO. < ' Insert | Contact Wire Operating | Rated 7 a Shell Part @ Sizes Voltage Current Size Number Maximum (Amps) (mm) | AWG |(mm)| Ac | DC * 00 113 1.3 | 20 | 1.0] 250) 400 8 113 os 116 16 | 18 | 1.4] 500] 700] 12 11608 1S 120 2.0 16 | 1.8] 600] 900 18 - . 130 3.0 12 | 2.7] 500] 700 25 1208 130 130 3.0 12 | 2.7] 700] 1000 30 ~ 2S 140 4.0 | 10 | 3.7] 600] soo] 40 130 | 140 140 4.0 10 | 3.7] 800] 1000 43 3S e @. 160 6.0 6 | 65] 600] 800 65 140 160. 140 4.0 10 | 3.7 | 1000 | 1400 46 4S e e 160 6.0 6 | 6.6] 900] 1300 70 140 _ 160 5S 112 12.0 4 |12.0] 500] 700| 230 112 : In some applications the female contact is required in the plug. Consult LEMO before specifying this feature. Note: All insert configurations shown are as viewed from the termination side of the plug. *Single coax connectors are available in this size. Please contact LEMO USA for a NIM-CAMAC catalog. Voltage Test Procedure PROCEDURE FOR DETERMINING TEST VOLTAGES AND WORKING VOLTAGES FOR LEMO CONNECTORS: *Test Voltage: Test voltages are determined by taking an average of the points at which. arcing occured and reducing it by 3. Working Voltage: Working voltages are determined by taking test voltages and reducing them further by 24. For high-voltage connectors, IEC publication 130-1 14.5 b) applies: Working voltage = Jest voltage 15 LEMO guarantees the proper functioning of the connector at working voltages. Although this may appear quite conservative, it is in keeping with LEMOs insistence on assuring proper functioning and maintenance of high-quality standards. Current ratings noted are per contact. The voltage used is the lesser of the two values; contact to contact or contact to shell. 64 TL LEME me ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesInsertsCoaxial* Shell Insert [Impedance] Type of | Cable | VSWR | Operating | Rated Size Part (2) Contact | Group | (GHz) Voltage Current Number ac | DC (Amps) os 250 50 e | 123-4] 1-02 ligoo}1400/ 6 +0.25f 250 50 e = |4-2-3-4-6] 1:' | 4000}1400/ 12 +0.23F 18 5-6 1.02 275 75 e omar | 800|1100] 10 1.01 = = e - os 250 50 67 | Gor | 1000| 1400] 15 250 G) 275.) 1.02 , - 275 75 e 6-7 | 'hGa | 500] 700] 12 250 50 8 1.06 |1000/1400| 26 + 0.5f as 275 75 e B | jst | 9001300] 15 250 \ a7 Nw 250 50 8-9 1.01 | zoo}/1000/ 36 . +1.9f 4S 1.01 275 75 e 8-9-0 600] 900} 26 250 275 +0.12f - 250 50 9 1.02 1000/1400] 45 + 2.3 5S 275 75 9-0 1.01 4000/1400] 36 250 . 275 +0.7f a = @ Available with either male or female contacts See page 77 for technical information on coax cables. Note: All insert configurations shown are as viewed from the termination side of the plug. See page 64 for Voitage Test Procedure. *LEMO also offers a line of miniature coaxial connectors, series 00-NIM-CAMAC & 01. Please contact LEMO for a catalog of these products. Recommended Coaxial Cable Group" 1|/2/3/4/5|6/7/8/0 Type RG.11A/U RG.12A/U RG.58C/U RG.59B/U RG.115A/U RG.122/0 RG.142B/U RG.144/U RG.165/U RG.174A/U RG.178B/U RG.179B/U RG.1B7A/U RG.188A/U Group 1[2|3]6]7[38]9 Type RG.196A/U RG.213/U RG.214/U RG.216/U RG.223/U RG.225/U RG.302/U RG.316/U RG.400/U HF-2114 Datwyler HF-5408/1 Datwyler 2YCCY 0.4/2.5 Siemens CCE 99.281.505 LEMO CCH.99.281.505 LEMO 4) The cable group number corresponding to the chosen cable must be written in the Variant position of the part number. RHIC ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 65S SeriesInsertsTriaxial @ Available with either male or female contacts Note: All insert configurations shown are as viewed from the termination side of the plug. See page 64 for Voltage Test Procedure. Recommended triaxial cables Group Group i2/3/4/5 Type a]5|617 Type e CTA.99.290.803 LEMO HF-2426 Datwyler e CTD.99.391.505 LEMO CTC.99.371.603 LEMO e 9222 Belden 12765700 F&G e 21.738 Amphenol 9267 Belden 118202 Filotex 10069-C-G20 BIW 21.204 Amphenol 12766400 F&G HF-2318 Datwyler 12766601 F&G 8215 Belden 8233 Belden 8232 Belden 9888 Belden 1) The cable group number corresponding to the chosen cable must be written in the Variant position of the part number. Shell Insert |Impedance| Type of | *Cable | VSWR (Operating|\OperatingiOperatingiOperating] Rated Size Part (Q) Contact | Group (GHz) | Voltage | Voltage | Voltage | Voltage | Current (AC) (AC) (DC) (DC) | (Amps) cy contact/ | shield/ | contact/ | shield/ . inner shield inner shield shield shield 1.1 * 00 650 50 e - sosst| 240 350 340 500 3 650 1.03 = os 650 50 12 | hea | 350 400 500 600 6 650 ) 1-2 1.01 ~ = 1S 650 50 e 2} Nor | 350 | 400 500 | 600 6 650 675 650 50 e 23 1.01 500 | 400 700 | 600 12 2 S 4 +0.3f 675 75 e 4-6 1.01 500 | 400 700 | 600 6 650 675 +0.07f f 650 50 e 34 1.01 soo | 400 | 1100 | 600 15 - 3S 5 +0.27f 675 75 45 1.02 600 | 400 go00 | 600 6 650 ZN 675 +0.05f | (S) (S) | 650 50 4-5 1.01 g00 | soo | 1300 | 800 26 . + 0.38f = 4S 4-5 1.01 675 75 : ota | 1000 600 1400 B00 15 66 kL LEME ELECTRONIC CONNE! ine CcCTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesInsertsMulti Contact Insert | Number | Contact Wire Operating | Rated 5, _ Shell Part of @ Sizes Voltage Current \ cy : Size Number | Contacts Maximum (Amps) [ t (mm) |AWG]|(mm)| AC | DC 302 2 0.9 22 | 08] 500] 700/ 10 OS || 303 3 0.7 | 26 | 06 | 300| 500|_ 8 & & 304 4 07 26 | 0.6 | 300| 500 7 302 303 304 302 2 13 20 | 1.0 | 400] 600/ 12 303 3 0.9 22 | 0.8! 400] 600/ 11 1S 304 4 0.9 22 | 0.8] 400/ 600] 10 . 2 | 0. 1 308 5 | o7 | 26 | oe | 99] 70} "7 a ai es issn sy 306 6 0.7 | 26 | 06 [| 500| 700 7 302 303 304 305 308 302 2 1.6 18 | 1.4 | 600] 900] 20 303 3 1.3 20 | 1.0 | 500] 7oo| 17 304 4 1.3 20 | 1.0 | 500] 7oo| 15 ~ ~, ae, 2S | 305 5 13 | 20 | 1.0 { 500] 7oo] 13 hee! ee 2 306 6 1.3 20 | 1.0 | 500] 700] 11 302 303 305 307 3 1.3 20 | 1.0 | 300] 400/ 10 4 0.9 22 | 0.8 | 300] 400 8 5 wr : = 308 8 0.9 | 22 [08] 300] 400/ 9 Mee fot Meg 28 310 10 09 | 22 | 08 | 300] 400|_ 8 306 307 308 310 302 2 2.0 16 | 1.8 /1000/1400] 23 303 3 2.0 16 | 1.8 [1000/1400] 20 304 4 2.0 16 | 1.8 | 500} 700] 18 o 305 2 20 | 1611.81 500| 7oo| 16 ee oe 3 1.3 20 | 1.0 | 500] 700 9 302 306 306 6 1.3 20 | 1.0 | 7oo|/1000/ 14 3S 307 7 1.3 20 | 1.0 | 300| 500| 12 308 8 1.3 20 | 1.0 | 300| 500] 10 310 10 1.3 20 | 1.0 | 300| 500 9 312 12 0.9 22 | 0.8 | 400| 600 8 313 13 0.9 22 | 0.8 | 400] 600 8 314 14 0.9 22 ) 0.8 | 400] 600 7 2, EE. (EES, Gay a 316 16 09 | 22 | 08 | 300] 500 7 Leese) ess lest ; lreeay lege! 318 18 0.9 22 | 0.8 | 300| 400 6 312 313 314 316 318 Note: All insert configurations shown are as viewed from the termination side of the plug. See page 64 for Voltage Test Procedures. PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 * telefax 707/578-0869 67S SeriesInsertsMulti Contact-continuea Insert | Number | Contact Wire Operating | Rated Shell Part of @ Sizes Voltage Current Size || Number | Contacts Maximum (Amps) cl (mm) [AWG |(mm)] AC | DC 302 2 40 | 10 | 3.7 | 700/1000] 35 7/7 = ~ ae. - 303 | 2 | 30 | 12 [27 | 700|100| 13 |, @, ,0, @, 0%, ot. 304 4 3.0 | 12 | 2.7 | 700]/1000/ 22 Oo a oo. Pc? 905 2 3.0 | 12 | 2.7 | 700/1000| 22 302 304 305 306 3 2.0 | 16 | 1.8 | 700/1000] 16 306 6 2.0 | 16 | 1.8 [| 700/1000/ 16 - _ 307 3 2.0 | 16 | 1.8 | 700|/1000/ 16 we 4 1.3 | 20 | 1.0 | 700|1000] 13 oye Se 4s 308 8 1.3. | 20 | 1.0 | 900[1300] 13 309 310 309 9 13 | 20 [1.0 | 700/1000/ 12 310 10 1.3 | 20 [1.0 | 7oo/1000/ 11 = = 312 12 1.3. | 20 | 1.0 | 700] 1000 9 yet tty 313 | 13 | 1.3 | 20 [10 | 700|1000/ 9 see 314 14 1.3. | 20 | 1.0 | 700/1000 7 316 316 16 0.9 | 22 | 08 | 700/1000 7 318 18 0.9 | 22 | 0.8 | 700|1000 7 chet 320 20 09 | 22 | 0.8 | 7oo[1000/ 7 | eae 322 22 09 | 22 | 08] 700]1000 7 = 324 24 09 | 22/08 | 7ooli000; 7 324 Note: All insert configurations shown are as viewed from the termination side of the plug. See page 64 for Voltage Test Procedures. 68 we L LEME. Mne ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesInsertsMulti Contactcontinuea 3 ' Insert | Number | Contact Wire Operating | Rated A =e ey Shell Part of 2 Sizes Voltage Current |g Size Number | Contacts Maximum (Amps) (mm) |AwWG|(mm)| AC | DC 302 2 6.0 5 | 5.5 |1100/1600| 50 303 | 2 | 4&0 | 10 | 37 [1100/1600 35 || @ ; ~ e e . . e 304 4 4.0 | 10 | 3.7 |1100/1600; 35 || ee ,_@e@ e eee 305 2 4.0 | 10 | 3.7 [1000/1400/ 35 ~ DoD So OLS 3 3.0 12 | 2.7 |1000]/1400} 25 a _ oss oa a 306 6 3.0 12 | 2.7 |1000]1400] 25 308 8 3.0 12 | 27 | 700/1000| 22 310 10 2.0 16 | 1.8 | 700/1000! 18 312 12 2.0 16 | 1.8 | 700|1000| 18 314 2 3.0 12 | 27 | 600] 800] 20 5S 12 2.0 16 | 1.8 | 600} 800} 15 316 16 2.0 16 | 1.8 | 600] 800; 15 318 2 3.0 12 | 2.7 | 600] 800; 18 16 1.6 18 | 1.4 | 600] B00] 11 320 20 1.6 18 | 1.4 | 600] B00] 11 399 2 3.0 12 | 2.7] 600] 800} 16 : a Saas = 20 1.6 18 | 1.4 | 600} 800 9 318 320 322 324 330 324 24 1.6 18 | 1.4 | 900 | 1300 9 a = oo 330 30 1.3 20 | 1.0 | 600| 800 8 336 36 1.3 20 | 1.0 | 600 800 7 340 40 1.3 20 | 1.0 | 400/ 600 7 344 44 1.3 20 | 1.0 | 400/ 600 6 348 48 1.3 20 | 1.0 | 400| 600 6 304 4 8.0 4 | 7.5 |1000]1400] 60 . See | OO oe otseee ; eee 320 20 | 30 | 12 | 27] 500| 700] 14 ~ s ay 324 24 | 3.0 | 12 | 27 [ 500| 700] 12 re 330 30 2.8 16 | 1.8 | 700/1100] 10 mo i 6S |" 336 36 | 20 | 16 | 18 500] 7oo| 8 304 312 318 348 48 20 | 16 | 18] 500] 700] 7 e e a. 360 60 1.6 18 | 1.4 | 500] 700 5 eee ee ee eee 362 62 1.6 18 | 1.4 | 500] 700 5 Ho 364 64 13 | 20 |1.0| 400/ 600| 4 ae aa 372 72 1.3 | 20 | 1.0 | 400] 600 4 - one 306 106 0.9 22 | 0.8 | 250/ 400 2 320 324 eee : eesone @eseeeonene Note: All insert configurations shown are as viewed from the : oeeee termination side of the plug. See page 64 for Voltage Test Procedures. 306 "Lh LEMME | nc ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 69S SeriesInsertsMixed High Voltage + Low Voltage ' . 4 Insert | Number HV Contact Wire Operating Rated i a J - Cy Shell Part of Dielectric @ Sizes Voltage Current [ _ {2 x Size Number | Contacts Maximum (Amps) (mm) [AWG|(mm)| Ac | DC HV 702 1HV 1.3 1.3 20 | 1.0 |2100]3000 6 2LV - 2.0 16 | 1.8] 500] 700] 18 703 1HV 1.3 1.3 | 20 | 1.0 [2100] 3000 6 3LV - 13 | 20 | 1.0 | 700}1000} 14 704 1HV 13 1.3 | 20 | 1.0 | 2000] 3000 6 4LV - 1.3 | 20 | 1.0 | 350} 500} 10 705 1HV 1.3 1.3 20 | 1.0 |2100/ 3000 6 5LV - 1.3 20 | 1.0 | 350] 500 9 706 1HV 1.3 1.3 20 | 1.0 [2100] 3000 6 3S 6LV - 1.3 20 | 1.0 | 350} 500 8 707 1HV 1.3 1.3 | 20 | 1.0 [2100/3000 6 7LV - 1.3 20 | 1.0 | 350] 500 8 . 708 1HV 1.3 1.3 20 | 1.0 |2100| 3000 6 gr e o e to 4/4LV - 1.3/.9 |20/22|1.0/.8] 350] 500] 6/8 708 709 711 24432 732 734 709 1HV 1.3 1.3 20 | 1.0 |2100] 3000 6 9LV - 9g 22 | 8 | 250] 400 6 744 1HV 1.3 1.3 | 20 | 1.0 [2100]3000 6 LV - 9 22 | 8 | 250| 400 6 432 2HV 1.3 1.3 20 | 1.0 |2100] 3000 6 730 2HV 1.3 1.3 20 | 1.0 |2100]3000 6 2LV - 1.3 20 | 1.0 | 700/1000] 14 734 2HV 1.3 13 20 | 1.0 | 2100/3000 6 4LV - 13 | 20 | 10 | 700/1000} 10 702 1HV 2.0 - 16 | 1.5 | 2100/3000 8 2LV - 3.0 12 | 2.7 | 700]}1000} 22 703 1HV 2.0 - 16 | 1.5 |2100] 3000 8 3LV - 2.0 16 | 1.8 | 700]}1000} 16 - tHV | 20 - | 16 | 15 [2100/3000/ 8 - . oe es am fav |] - 13 | 20 | 10 | goo/1300} 13 [Jn @ Pe 8 8. tt wos | WAV | 20 - 16 | 1.5 |2100/3000/ 8 - * e* 5LV - 1.3 | 20 | 1.0 700/1000; 11 702 703 704 705 706 1HV 2.0 - 16 | 1.5 |2100/ 3000 8 6LV - 1.3 | 20 | 1.0 | 700] 1000 9 707 1HV 2.0 - 16 | 1.5 | 2100] 3000 8 7LV - 1.3 20 | 1.0 | 700] 1000 9 708 1HV 2.0 - 16 | 1.5 [2100] 3000 8 8LV - 1.3 20 | 1.0 | 700] 1000 9 509 1HV 2.0 - 16 | 1.5 |2100] 3000 8 OLV - 9 22 | .8 | 700} 1000 7 710 1HV 2.0 - 16 | 1.5 |2100/ 3000 8 10LV - 9 22 | .8 | 700] 1000 7 4S 740 1HV 2.0 - 16 | 1.5 |2100] 3000 8 12LV - 9 22 | .8 | 700] 1000 7 744 1HV 2.0 - 16 | 1.5 [2100/3000 8 14LV - 9 22 | .8 | 700] 1000 7 _ - +46 | 1HV | 20 - 16 | 1.5 [2100/3000 8 ||, | ee, 16LV - 9 22 | .8 | 500] 700 6 Gs 442 2HV 1.3 - 16 | 1.5 | 3500] 5000 8 739 2HV 2.0 - 16 | 1.5 [2100/3000 8 442 732 OLV ~ 3.0 12 | 2.7 | 700|1000| 22 733 2HV 2.0 - 16 | 1.5 |2100/3000/ - 3LV - 2.0 16 | 1.8 | 700]1000] 16 744 2HV 2.0 - 16 | 1.5 |2100/3000/ 4LV - 1.3 20 | 1.0 | 900]1300] 13 See page 76 for technical information on high voltage contacts. Single and multi contact high voltage connectors are also available. For more information on these please contact LEMO USA or mail in the postcard in the back of this catalog. Note: All insert configurations shown are as viewed from the termination side of the plug. See page 64 for Voltage Test Procedures. 70 L LEME ELECTRONIC CONNE ~WIeC crorms PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesInsertsMIXxed-=nigh voltage + Low Voltage-continued | Qa ' Insert | Number HV Contact Wire Operating Rated i aL Shell Part of Dielectric) Sizes Voltage | Current eo Size Number | Contacts Maximum (Amps) (mm) |AWG|(mm)} AC | DC HV 735 2HV 2.0 - 16 | 1.5 [2100/3500 - 5LV - 13 20 | 1.0 | 700/1000] 11 7 - - 736 2HV 2.0 - 16 | 1.5 | 2100/3000 - ee : 6LV - 1.3 20 | 1.0 | 700] 1000 9 i. 737 2HV 2.0 - 16 | 1.5 |2100] 3000 - 7LV - 1.3 20 | 1.0 | 700] 1000 9 4S 739 2HV 2.0 - 16 | 1.5 |2100| 3000 - ; 9LV - Q 22 .8 | 700] 1000 7 ; 740 2HV 2.0 - 16 | 1.5 |2100] 3000 - a 10LV - 9 22 | .8 | 700] 1000 7 - SI 742 2HV 2.0 - 16 | 1.5 |2100] 3000; = - 740 742 433 434 12LV - 9 22 8 | 700] 1000 7 433 3HV 2.0 - 16 | 1.5 |2100] 3000/ = - 434 4HV 2.0 - 16 | 1.5 |2100] 3000] = - 706 1HV 2.0 - 16 | 1.5 |3500/ 5000; = - _. 6LV - 2.0 16 | 1.8 | 700] 1000] 18 oo ee aoe, e%e 70g | 1HV | 20 - 16 | 1.5 |3500| 5000] - ef %e f* *% 0 8LV - 2.0 16 | 1.8] 400] 600] 15 : : 5 0 O'6! 710 | 1HV 2.0 - 16 | 1.5 |3500| 5000} - PoP 10LV - 1.6 18 | 1.2 | 600] 800} 14 706 708 710 730 730 1HV 3.0 - 16 | 1.5 |7000 10000] = - 10LV - 2.0 16 | 1.8 | 400] 600) 15 = a aa covese e e e* *. e@-; 6 724 1HV 2.0 - 16 1.5 |3500 |} 5000 - eeesecoe e e e e e "@o eo. 24LV - 1.3 20 | 1.0 | 400] 600 6 aa en 734 2HV 2.0 - 16 | 1.5 13500] 5000} = - z! Bee oS m5 4LV - 3.0 12 | 2.7 | 700] 1000) 22 an a moe 736 2HV 2.0 - 16 | 1.5 |3500] 5000) - 724 734 736 738 5S 6LV - 2.0 16 | 1.8 | 700} 1000} 18 a _ _. 738 2HV 2.0 - 16 | 1.5 |3500] 5000 we one a On aLv - 2.0 | 16 | 1.8 | 700| 1000] 15 J] 2 %s, of S'S 740 2HV 2.0 - 16 | 1.5 |3500/ 5000; = - O'S: Saad Oi #04 Gi SO, 10LV - 1.6 18 | 1.2 | 600] soo} 11 os - ~ og = 2HV 2.0 - 16 | 1.5 [3500] sooo] = - AD aA 4 a 7 740 754 764 782 54 | av | 8 13 | 20 | 1.0 | 400| 600| 6 764 3HV 2.0 - 16 | 1.5 |3500/ 5000; - = = 4LV - 2.0 16 | 1.8 | 400] 600] 18 3 ee 782 4HV 2.0 - 16 | 1.5 |3500] 5000} - > Hoa 2LV - 2.0 16 | 1.8 | 400] 600) 18 iS oN 442 2HV 2.0 - 16 | 1.5 |3500| 5000] = - secu 443. | 3Hv | 2.0 - 16 | 1.5 |3500| 5000; a4e 443 444 4HV 2.0 - 16 | 1.5 |3500] 5000] = - 438 8HV 2.0 - 16 | 1.5 |2100] 3000] = - See page 76 for technical information on high voltage contacts. Single and multicontact high voltage connectors are also available. in the postcard in the back of this catalog. For more information on these please contact LEMO USA or mail Note: All insert configurations shown are as viewed from the termination side of the plug. See page 64 for Voltage Test Procedures. L LEM L-. "TC ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 * telefax 707/578-0869 71S SeriesInsertsMixed-coaxial + Low Voltage See page 64 for Voltage Test Procedures. Contact Type: Solder only Coax Type: See pages 76-77. s ' Shell Insert | Number | Coax & | Contact | Solder | Coax | Operating | Rated = an Size Part of Multi- @ Wire Cable Voltage Current [ |, , Number | Contacts | contact AWG Group (Amps) Type | (mm) Ac | DC Coax 1 coax Al 1-2-3 | 700] 1000 4 go1__| 50 ohm 1 multi | Solder 1.3 20 900 | 1300 14 1 coax Al 1-2-3 | 700] 1000 4 802 50 ohm 2 multi | Solder 1.3 20 400] 600 14 1 coax Al 1-2-3. | 700| 1000 4 gos | 820hm : - oe 3multi | Solder | 1.3 20 900|1300} 14 @. : , @ tcoax | At 1-2-3 | 7ool1ooo; 4 801 B02 803 3S go4 | 20 0hm 4 mult Solder 1.3 20 400] 600 10 1 coax Al 1-2-3 | 700| 1000 4 wt ave oe sth gos | 30 ohm o 6" Ss Se 5 multi | Solder 0.9 22 600} 800 8 804 805 806 807 1 coax Al 1-2-3 | 700| 1000 4 806 50 ohm 6 multi | Solder 1.3 20 250 | 400 8 1 coax Al 1-2-3 700 | 1000 4 807 50 ohm 7 multi | Solder 0.9 22 250| 400 7 1 coax Al 1-2-3 700 | 1000 4 802 50 ohm 2 multi | Solder 3.0 12 700|1000| 22 1 coax Al 1-2-3 | 700] 1000 4 803 | 50 ohm 3 multi | Solder 2.0 16 700 | 1000 16 a. as 1coax | At 1-2-3 | 700 | 1000 4 28; ele) ees ; g04 | 50 ohm O ' ' 4multi | Solder | 1.3 20 900} 1300] 13 g02 803 804 1 coax Al 1-2-3 | 700 | 1000 4 805 50 ohm 4s 5 multi | Solder 1.3 20 700|1000] 11 1 coax Al 1-2-3. | 700/1000 4 806 50 ohm 6 multi | Solder 1.3 20 700 | 1000 9 1 coax Al 1-2-3. | 700 | 1000 4 807 | 50 ohm 7 multi | Solder 1.3 20 700 | 1000 8 1 coax Al 1-2-3 700 | 1000 4 B09 50 ohm 9 multi | Solder 0.9 22 700 | 1000 7 1 coax Al 1-2-3 | 700/ 1000 4 B10 50 ohm 10 multi | Solder 0.9 22 700 | 1000 7 * See page 77 for cable groups. Note: All configurations shown are as viewed from the termination side of the plug. 72 Lk LEM ELECTRONIC CONNE mie cCTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) * (707) 578-8811 telefax 707/578-0869S SeriesInsertsMixed-coaxial + Low Voltage-continued Contact Type: Solder only Coax Type: See pages 76-77. See page 64 for Voltage Test Procedures. Shell Insert | Number Coax & Contact | Solder *Coax | Operating | Rated <E Oo Size Part of Multi- @ Wire Cable Voltage Current | Number | Contacts | contact AWG Group (Amps) Type | (mm) ac | DC Coax 1 coax Al 1-2-3 700 | 1000 4 812 50 ohm 12 multi | Solder 0.9 22 700 | 1000 7 202 oom Al 1-2-3 700 | 1000 4 2 coax Al 1-2-3 700 | 1000 4 832 50 ohm 2 multi | Solder 1.3 20 700 | 1000 13 2 coax Al 1-2-3 700 | 1000 4 834 50 ohm 4 multi | Solder 1.3 20 700 | 1000 13 4S 2 coax Al 1-2-3 700 | 1000 4 836 50 ohm 6 multi | Solder 0.9 22 600 | 800 7 2 coax Al 1-2-3 700 | 1000 4 838 50 ohm 8 multi | Solder 0.9 22 600! 800 7 2 coax Al 1-2-3 700 | 1000 4 842 50 ohm 12 multi | Solder 0.9 22 600 | 800 7 1 coax AO 1-2-6 600 | 800 6 804 50 ohm 4 multi | Solder 3.0 12 700 | 1000 22 B10 1 coax Al 1-2-3 700 | 1000 4 50 ohm + 10 multi | Solder 1.6 18 600 | 800 1 232 2 coax AO 1-2-6 | 1000] 1400 6 50 ohm 2B? gcoax Al 6 1000 | 1400 12 292 roux A 4-5-7 800 | 1100 10 2 coax AO 1-2-6 | 1000 | 1400 6 832 50 ohm | 2 multi | Solder 2.0 i6 700 | 1000 18 5S 2 coax AO 1-2-6 | 1000 | 1400 6 834 50 ohm 4 multi | Solder 2.0 16 700 | 1000 18 2 coax AO 1-2-6 | 1000 | 1400 6 838 50 ohm 8 multi | Solder 1.6 18 600} 800 12 2 coax AO 1-2-6 | 1000 | 1400 6 842 50 ohm 12 multi | Solder 1.3 20 600} 800 9 2 coax AO 1-2-6 | 1000] 1400 6 846 50 ohm 16 multi | Solder 1.3 20 250| 400 8 * See page 77 for cable groups. Note: All configurations shown are as viewed from the termination side of the plug. Ae L LEM ine ELECTRONIC CONNECTORS PO, Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) * (707) 578-8811 telefax 707/578-0869 73S SeriesInsertSMixed-coaxial + Low Voltage cont. Contact Type: Solder only Coax Type: See pages 76-77. See page 64 for Voltage Test Procedures. S ' Shell Insert | Number | Coax &| Contact | Solder | *Coax Operating | Rated i . Size Part of Multi- @ Wire Cable Voltage Current a Number | Contacts | contact AWG Group (Amps) Type | (mm) Ac | DC Coax 2 coax A 4-5-7 800 | 1100 10 846 75 ohm 16 multi] Solder | 1.3 20 250| 400/ 8 . O . 2coax | AO 1-2-6 | 1000 | 1400 6 eT 50 ohm Poo 88. 850 oO 20 multi] Solder | 1.3 20 250| 400 7 5S 2coax | AO 1-2-6 [1000/1400[ 6 850 24 multi| Solder | 1.3 20 250| 400/ 6 CA _ . 8 4 coax Al 1-2-3 | 700] 1000 4 : 208, Oo 9 2 9 . 234 50 oh 500 esa) = "oO -_ O onm 9 9O @ 4 coax Al 1-2-3 700 | 1000 4 Mo Te _ Qe 876 | 50 ohm ~ ~ ~ + 854 234 876 6 multi | Solder 1.3 20 250 | 400 6 1coax | AO 1-2-6 | 1000| 1400 6 826 50 ohm _. 26 multi| Solder | 2.0 16 500 | 700 7 ete? n'ee 1 coax A 4-5-7 | 800} 1100 10 , @eeoocee, 826 75 ohm . CS SS | 26 multi| Solder | 2.0 | 16 500| 700] 7 cere (Oe = tcoax | A 6 |1000/1400/ 12 eoee 506. eeeeees 830 50 ohm e eee cece | ee eovoces. 4/30 multi| Solder | 3.0/1.6 | 12/18 | 4-5-7 | 500] 700] 14/5 " "29 x OO! Oo 3 LO 1 coax A 6 800 | 1100 10 eee QO ~ 830 6 ohm . B26. : eovccve 330 4/30 multi] Solder | 3.0/1.6 | 12/18 | 4-5-7 | 500| 700| 10/14 peseosecee. 2 coax A 4-5-7 | 800] 1100 10 mS _ fa g57_ | 7S ohm __ O : a + oe ena SS * 6S 33 multi] Solder | 1.3 20 400| 600] 4 Cone eee aa : 2 coax A 6 |1000/1400! 12 j Oo Oo eens gg | 50 ohm OF FSB ttre + 6@13 20 4 4 eee e oo ae oe ! . e c o 34 muiti| Solder |O@ 1.6) 18 400} 600/ . \eeeeee 3 5@2.0| 16 10 * nae, 17@09| 22 2 857 : B58 2coax | A 45-7 | 700]1000] 10 ieee... gsa_| 75 ohm [IS 5 + 6@09]} 20 4 34 multi] Solder |6@0.9| 18 400 | 600 5 5 @ 0.9 16 10 eee 17 @ 0.9 22 7 ; eovevecce 2coax | Al 1-2-3 | 700 | 1000 4 jocessesees: 859 50 ohm \ Oo oO 40 multi | solder | 1.3/3.0 | 20/12 400| 600) 4/14 3 coax Ad 1-2-6 | 1000 | 1400 6 26 multi] Solder | 2.0 16 400| 600 7 3 coax A 4-5-7 | 800/ 1100 10 ow ges | 75 ohm 866 26 multi] Solder | 1.3 16 500 | 700 4 *See page 77 for cable groups. Note: All insert configurations shown are as viewed from the termination side of the plug. 74 L LEM - " ELECTRONIC CONNECTORS ine PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S SeriesInsertsMixed-coaxial + Low Voltage cont. Contact Type: Solder only Coax Type: See pages 76-77. Shell Insert | Number | Coax & | Contact | Solder | Coax | Operating | Rated Size Part of Multi- @ Wire Cable Voltage Current Number | Contacts | contact AWG Group (Amps) Type | mm) Ac | DC 4 coax A _ _ 6 1000 | 1400 12 _ 284 ~ 50 ohm 4 coax A 6 800 | 1100 10 ~ oo, 294 | 75 ohm 4 coax Al 1-2-3 700 | 1000 4 880 50 ohm S ; f 20 mutti| Solder | 1.3 20 400{ 600] 4 OO n4 . . 4coax | A 45-7 | 800]1100| 10 Oo 882 75 ohm ~ ! ~ 0 26 multi | solder 0.9 22 250) 400 2 a . * 144 | A3&Al 9& |1000|1400| 26 380. : 20a coax 1-2-3 (& 70081000 &4 . 6S 50 ohm :. 887 + cee - 7 multi | Solder | 2.0 16 - | 500} 700] 10 EE 6 coax Al 1-2-3 | 700] 1000 4 eee 50 ohm e ; e@ 882 . . 890 + Oo O09 O 4 multi | Solder 4.0 10 - 500} 700 16 Oo eQ QO 6 coax | At 1-2-3 | 700] 1000 4 - Oy oO 50 ohm - 7 , mes * B90 COOCSS 887 20 multi | Solder 1.6 18 - 500} 700 5 CooO ooo 8coax | AO _ _ 1-2-6 | 1000 | 1400 6 ~ ~ 238 | 50 ohm = Qo Bcoax | Al 1-2-3 5 96 -= 899 ohm . *vooce _ 893 _ O: _ 20 multi| Solder | 1.6 18 500! 700 7 : O'S ee 2 . : i Oo Oo >_ *See page 77 for cable groups. = ro! ~ oO eas ) Note: All insert configurations shown are as viewed from the termination side of fase an 899 238 the plug. See page 64 for Voltage Test Procedures. L LEMME | inc Stee TRONIG CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) * (707) 578-8811 telefax 707/578-0869 7 5S Series Technical Information Example of high voltage contact construction for mixed high voltage and multi high voltage connectors. The high voltage contact is permanently fixed into the inserts. The conductor is secured by solder. Surface Treatment Component Material (um) Cu | Ni | Au 1 Insert PTFE (ASTM D 1457-83) 2 Male Contact Brass (UNS C 385) os | 3 | 15 Solder 3 Insert PTFE (ASTM D 1457-83) OO 4 Female Contact Bronze (UNS C 544) 0.5 3 | 25 5 Insert Tube PTFE (ASTM D 1457-83) 6 Clips Brass (UNS C 385) o5 | 3 | Examples of coaxial contact construction for mixed coax and multi coax connectors Coaxial, Type AO, A, Al and type A3 The coaxial of this type is permanently fixed into the insert. The conductor is secured by solder and the shield by crimping. The coax contact is permanently fixed into the insert. The conductor is secured by solder and the shield by crimping. Surface Component Material treatment (um) Cu | Ni | Au 1 Male Sleeve Brass (UNS C 385) o5 | 3 [15 2 Insert PTFE (ASTM D 1457-83) 3 Male Contact Brass (UNS C 385) 05 3 15 4 Female Sleeve Bronze (UNS C 544) 05 3 20 5 Insert PTFE (ASTM D 1457-83) 6 Female Contact || Bronze (UNS C 544) 05 | 3 | 25 Solder 7 Insulating Sleeve || PTFE (ASTM D 1457-83) 8 Grounding Sleeve || Brass (UNS C 385) 05 3 9 Collet Brass (UNS C 385) 05 3 10 Ferrule Brass (UNS C 385) 05 3 DL LEM nc ELECTRONIC CONNECTORS 76 PO, Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S Series Technical Information-continued Technical characteristics of coax contacts The coaxial part is permanently fixed in the main insert. The inner conductor of the cable is soldered to the contact while the outer conductor is clamped by the collet. Characteristic Unit Type Type Type Type Impedance 2 50 75 50 50 50 Operating voltage || ac | goo | soo | 1000 | 300 | 1000 at 50 Hz Test voltage ac | 1800 | 2400 | 300 | 900 | 3000 at 50 Hz Rated current A 12 7 7 5 15 Insulating >102 | >107 | >102 | >10% | >107 resistance 1900 1 (MHz) Contact me | 20 | 29 | 45 | 38 | 20 resistance , , , . . Shell to shell me | 18 | 18 | 10 | 30 | 10 resistance _ 101 | 1.01 | 106 | 101 | 1.06 VSWR (f = GHz) +0.146f| +0.19f| +0.1f |4+0.127f] +0.5f Contact Specifications Solder contacts, max. inner conductor diameter Contact Conductor max. AWG OG | OH max. solid | stranded 0.7 | 06 0.55 24 26 09 | 08 0.75 22 22 13 | 10 0.95 20 20 16 | 14 1.35 16 18 20) 18 1.75 14 16 25 | 4.00 3.95 10 10 30 | 2.7 2.65 14 16 49 [37 || 365 [90 [10 | cottact, values are 60 | 54 5.35 - 8 3.0, 2.95, 12, 14. 80 | 70 695 - . : . 120 | 62 6.15 ~ 4 rein millimeters Recommended coaxial cables for mixed coax and multicoax connectors Group Group 1[3/4[5|e[7|| YPe 1/2]3]5[6|7 Type e RG.68C/U RG.188A/U e RG59B/U RG.196A/U RG.115A/U RG.213/U RG.122/U RG.223/U RG.142B/U RG.302/U RG.165/U RG.316/U RG.174A/U RG.400/U RG.178B/U CCE.99.281.505 LEMO 1) The cable group number corresponding to the chosen cable must be written in the Variant position of the part number. Lh LEME = inc - ELECTRONIC CONNECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 T7S Series Collets Part Number OS: Reference Collet @ Cable @ Series (mm) (mm) Cater Fart Note Oversized Collet | Oversized Collet Nut Type 2 OA OB max. min. (If ordered separately) (For type K Collets) (For type K Collets) Cc 15 1.5 - 1.4 1.2 FFA.00.715.CN oO Cc 17 1.7 1.5 1.6 1.5 FFA.00.717.CN oC Cc 22 2.2 - 2.1 1.7 FFA.00.722.CN e Cc 27 2.7 - 2.6 2.2 FFA.00.727.CN e Cc 29 29 2.7 2.8 2.7 FFA.00.729.CN e Cc 31 3.1 2.4 3.0 2.8 FFA.00.731.CN e K 37 00 3.7 3.2 3.6 3.0 FFA.0S.737.CN @ FFA.00.137.LCN FFA.0S.130.LC K 42 4.2 3.7 4.1 3.3 FFA.0S.742.CN e FFA.00.137.LCN FFA.0S.130.LC Cc 16 1.6 - 1.5 1.3 FFC.00.716.CN @1) Cc 19 1.9 1.6 1.8 1.6 FFC.00.719.CN 1) Cc 22 2.2 1.6 2.1 1.9 FFC.00.722.CN e1 Cc 27 2.7 1.6 2.6 2.2 FFC.00.727.CN @') Cc 31 3.1 2.4 3.0 2.7 FFC.00.731.CN @') Cc 17 1.7 - 1.6 1.3 FFA.0S.717.CN Co CG 22 2.2 - 2.1 1.7 FFA.0S.722.CN Cc Cc 27 2.7 - 2.6 2.2 FFA.0S.727.CN e Cc 32 3.2 - 3.1 2.7 FFA.0S.732.CN e Cc 37 3.7 3.2 3.6 3.0 FFA.OS.737.CN e Cc 42 4.2 3.7 4.1 3.3 FFA.0S.742.CN e Cc 44 4.4 3.7 4.3 3.5 FFA.0S.744.CN Oo K 47 4.7 - 46 3.8 FFA.1S.747.CN FFA.0S.137.LCN FFA.1$.130.LC K 52 .2 - 5.1 4.3 FFA.1S.752.CN FFA.0S.137.LCN FFA.18.130.LG K 57 5.7 - 56 4.8 FFA.1S.757.CN FFA.0S.137.LCN FFA.1S.130.LC K 62 os 6.2 5.2 6.1 5.3 FFA.1S.762.CN @ FFA.0S.137.LCN FFA.1S.130.LC K 66 6.6 5.5 6.5 5.9 FFA.1S.766.CN CO FFA.0S.137.LCN FFA.1S.130.LC K 68 6.8 5.5 6.7 6.0 FFA.1S.768.CN oI FFA.0S.137.LCN FFA.1S.130.LC Cc 17 1.7 - 1.6 1.3 FLA.0S.717.CN 2) Cc 22 2.2 - 2.1 1.7 FLA.0S.722.CN C2) Cc 27 2.7 - 2.6 2.2 FLA.0S.727.CN @2) Cc 32 3.2 - 3.1 2.7 FLA.0S.732.CN @2) Cc 37 3.7 3.2 3.6 3.0 FLA.0S.737.CN e2 Cc 42 4.2 3.7 4.1 3.3 FLA.OS.742.CN @2 Cc 44 4.4 3.7 4.3 3.5 FLA.0S.744.CN 2) C =Shielded S Series Collet K = Oversized S Series Collet requiring the use of an oversized collet and nut. 1) These cannot be used with model FLA. 2) These can be used with models FLA, FFP and PCP. @ Available 2) Special order 78 PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 * telefax 707/578-0869 L LEME. P---- 7 IG ELECTRONIC CONNECTORSS Series Collets-continuea Part Number 7 OF @, 3. g| al Reference Collet @ Cable @ (mm) (mm) Collet Part Oversized Collet Oversized Collet Nut Series Number Note (For type K Collets) (For type K Collets) Type @ @A | @B | max. min. _| (If ordered separately) Cc 17 1.7 - 1.6 1.3 FFA.1S.717.CN & Cc 22 2.2 - 2.1 1.7 FFA.1S.722.CN Oo Cc 27 2.7 - 2.6 2.2 FFA.1S.727.CN e Cc 32 3.2 - 3.1 2.6 FFA.18.732.CN e@ Cc 37 3.7 - 3.6 2.7 FFA.1S.737.CN e Cc 42 4.2 - 41 3.3 FFA.1S.742.CN e Cc 47 4.7 - 4.6 3.8 FFA.1S.747.CN e Cc 52 5.2 - 5.1 4.3 FFA.1S.752.CN e Cc 57 5.7 - 5.6 4.8 FFA.1S.757.CN e Cc 62 6.2 5.2 6.1 5.3 FFA.1S.762.CN e Cc 66 6.6 5.5 6.5 5.9 FFA.1S.766.CN e Cc 68 6.8 5.5 6.7 6.0 FFA.1S.768.CN oC K 72 7.2 6.7 7.0 6.1 FFA.2S.772.CN e FFA.1S.137.LCN FFA.28.130.LC K 77 18 7.7 6.7 75 7.1 FFA.2S.777.CN FFA.1S.137.LCN FFA.2S.131.LC K 82 8.2 6.7 8.0 7.6 FFA.2S.782.CN Q FFA.1S.137.LCN FFA.2S.131.LC K 87 8.7 6.7 8.5 8.1 FFA.2S.787.CN Cc FFA.1S.137.LCON FFA.2S.131.LC Cc 17 1.7 - 1.6 1.3 FLA.18.717.CN 1) Cc 22 2.2 - 2.1 1.7 FLA.18.722.CN O1) Cc 27 2.7 - 2.6 2.2 FLA.1S.727.CN @1) Cc 32 3.2 - 3.1 2.6 FLA.1S.732.CN @ 1) c 37 3.7 - 3.6 2.7 FLA.1S.737.CN @1) c 42 4.2 - 4.1 3.3 FLA.1S.742.CN @ 1) Cc 47 4.7 - 4.6 3.8 FLA.1S.747.CN @1) Cc 52 5.2 - 5.1 4.3 FLA.18.752.CN @1) Cc 57 5.7 - 5.6 4.8 FLA.1S.757.CN @1) Cc 62 6.2 5.2 6.1 5.3 FLA.1S.762.CN @1) Cc 66 6.6 5.5 6.5 5.9 FLA.1S.766.CN @1) Cc 68 6.8 5.5 6.7 6.0 FLA.1S.768.CN 1) C=Shielded S Series Collet K = Oversized S Series Collet requiring the use of an oversized collet and nut. 1) These can be used with model FLA and FFP. @ Available Special order "Lh LEME ELECTRONIC CONNECT PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) * (707) 578-8811 telefax 707/578-0869 nme ORs 79S Series Collets-continuea iv a OF 4 2 ci) 5 Part Number Collet @ Cable 2 Reference (mm) (mm) Collet Part : . Series Number Note Oversized Collet Oversized Collet Nut Type g OA OB max. min. (If ordered separately) (For type K Collets) (For type K Collets) c 17 1.7 - 1.5 1.3 FFA.2S.717.CN So Cc 27 2.7 - 2.5 1.7 FFA.2S.727.CN oO Cc 32 3.2 - 3.0 2.5 FFA.2S.732.CN O Cc 42 4.2 - 4.0 3.1 FFA.2S.742.CN e Cc 52 5.2 - 5.0 4.1 FFA.2S.752.CN Cc 62 6.2 - 6.0 5.1 FFA.2S.762.CN e Cc 72 7.2 6.7 7.0 6.1 FFA.2S.772.CN @ Cc 77 7.7 6.7 7.5 7A FFA.2S.777.CN Cc 82 8.2 6.7 8.0 7.6 FFA.2S.782.CN o Cc 87 8.7 6.7 8.5 8.1 FFA.2S.787.CN co K 92 9.2 3.7 9.0 8.1 FFA.3S.792.CN @ FFA.28.137.LCN FFA.3S.130.LC K 97 9.7 8.7 9.5 9.1 FFA.3S.797.CN e FFA.2S.137.LCN FFA.3S.131.LC K 10 2s 10.2 8.7 10.0 9.6 FFA.3S.710.CN oO FFA.2S.137.LCN FFA.3S.131.LC K 11 10.7 8.7 10.5 10.1 FFA.3S.711.CN e FFA.28.137.LCN FFA.3S.131.LC c 17 1.7 - 1.5 1.3 FLA.2S.717.CN O11) Cc 27 2.7 - 2.5 1.7 FLA.2S.727.CN 1 Cc 32 3.2 - 3.0 2.5 FLA.2S.732.CN O1) Cc 42 4.2 - 4.0 3.1 FLA.2S.742.CN @1) Cc 52 5.2 - 5.0 41 FLA.2S.752.CN @1) Cc 62 6.2 - 6.0 5.1 FLA.2S.762.CN @1) Cc 72 7.2 6.7 7.0 6.1 FLA.28.772.CN @1) Cc 77 7.7 6.7 7.5 7.1 FLA.2S.777.CN @1) Cc 82 8.2 6.7 8.0 7.6 FLA.2S.782.CN 1) Cc 87 8.7 6.7 8.5 8.1 FLA.2S.787.CN O1) Cc 42 4.2 - 4.0 3.1 FFA.3S.742.CN oO Cc 52 5.2 - 5.0 4.1 FFA.3S.752.CN e Cc 62 6.2 - 6.0 5.1 FFA.3S.762.CN e Cc 72 7.2 - 7.0 6.1 FFA.3S.772.CN e Cc 82 8.2 - 8.0 7.1 FFA.3S.782.CN e c 92 9.2 8.7 9.0 8.1 FFA.3S.792.CN e Cc 97 9.7 8.7 9.5 9.1 FFA.3S.797.CN e Cc 10 10.2 8.7 10.0 9.6 FFA.3S.710.CN oO Cc 11 10.7 8.7 10.5 10.1 FFA.3S.711.CN K 12 12.0 - 12.0 44.4 FFA.4S.712.CN FFA.3S.137.LCN FFA.4S.130.LC K 13 3S 13.2 12.2 13.0 12.1 FFA.4S.713.CN e FFA.3S.137.LCN FFA.4S.131.LC Cc 42 4.2 - 4.0 3.1 FLA.3S.742.CN O1) Cc 52 5.2 - 5.0 44 FLA.3S.752.CN @1) Cc 62 6.2 - 6.0 541 FLA.3S.762.CN @1) Cc 72 7.2 - 7.0 6.1 FLA.3S.772.CN @1) Cc 82 8.2 - 8.0 7.1 FLA.3S.782.CN @1) Cc 92 9.2 8.7 9.0 8.1 FLA.3S.792.CN @1) c 97 9.7 8.7 9.5 9.1 FLA.38.797.CN @1) Cc 10 10.7 8.7 10.5 9.8 FLA.3S.710.CN @1) Cc 11 10.7 8.7 10.5 10.1 FLA.3S.711.CN @1) C =Shielded S Series Collet K = Oversized S Series Collet requiring the use of an @ Available oversized Collet and nut. 1) These can be used with models FLA, FFP and PCP Special order 80 PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 L LEME nc ELECTRONIC CONNECTORSS Series ColletScontinued _- ee 4 Ss Z e/ Ss Part Number Collet @ Cable @ , (mm) (mm) Collet Part Oversized Collet Oversized Collet Nut Series Number Note (For type K Collets) (For type K Collets) Type @ OA @B_ | max. min. _ | (If ordered separately) Cc 52 5.2 - 5.0 41 FFA.4S.752.CN & Cc 62 6.2 - 6.0 5.1 FFA.4S.762.CN o Cc 72 7.2 ~ 7.0 6.1 FFA.4S.772.CN @ c 82 8.2 - 8.0 7 FFA.4S.782.CN @ Cc 92 9.2 - 9.0 8.1 FFA.4S.792.CN e c 10 10.2 - 10.0 9.1 FFA.48.710.CN e@ Cc 11 11.2 - 11.0 10.1 FFA.4S.711.CN Cc 12 12.2 - 12.0 114 FFA.4S.712.CN Cc 13 12.7 12.2 12.5 12.1 FFA.4S.713.CN e Cc 13 13.2 12.2 13.0 12.1 FFA.4S.713.CN e@ K 14 14.2 - 14.0 13.1 FFA.5S.714.CN Oo FFA.4S.137.LCN FFA.5S.130.LC K 15 15.2 - 15.0 14.1 FFA.5S.715.CN e@ FFA.48.137.LON FFA.5S.130.LC K 16 16.2 - 16.0 15.1 FFA.5S.716.CN oO FFA.4S.137.LON FFA.5S.130.LC K 17 17.2 - 17.0 16.1 FFA.5S.717.CN oO FFA.4S.137.LCON FFA.5S.130.LC K 18 48 18.2 - 18.0 17.1 FFA.5S.718.CN 2 FFA.4S.137.LCN FFA.5S.130.LC K 19 19.2 - 19.0 18.1 FFA.5S.719.CN co FFA.4S.137.LCON FFA.5S.130.LC K 20 20.2 19.7 20.0 19.1 FFA.5S.720.CN e FFA.4S.137.LCON FFA.5S.130.LC K 21 21.2 19.7 21.0 20.1 FFA.5S.721.CN a FFA.4S.137.LCN FFA.5S.130.LC K 22 22.2 19.7 22.0 21.1 FFA.5S.722.CN e@ FFA.4S.137.LCN FFA.5S.131.LC Cc 52 5.2 - 5.0 41 FLA.4S.752.CN 1) Cc 62 6.2 - 6.0 5.1 FLA.4S.762.CN 1) Cc 72 7.2 - 7.0 6.1 FLA.4S.772.CN @ 1) Cc 82 8.2 - 8.0 7.1 FLA.4S.782.CN @1) Cc 92 9.2 - 9.0 8.1 FLA.4S.792.CN @1) Cc 10 10.2 -~ 10.0 9.1 FLA.4S.710.CN @1) Cc 11 11.2 - 11.0 10.1 FLA.4S.711.CN @1) Cc 12 12.2 - 12.0 11.1 FLA.4S.712.CN @ 1) Cc 13 12.7 12.2 12.5 12.1 FLA.4S.713.CN @1) C = Shielded S Series Collet 1) These can be used with models FLA, FFP and PCP. K = Oversized S Series Collet requiring the use of an @ Available oversized collet and nut. Special order LEMME |... 28 81 PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) * (707) 578-8811 telefax 707/578-0869S Series Colletscontinued 3 Part Number Collet @ Cable @ Reference (mm) (mm) Collet Part i i Series Number Note Oversized Collet Oversized Collet Nut Type o OA OB max. min. (If ordered separately) (For type K Collets) (For type K Collets) Cc 72 7.2 - 7.0 6.1 FFA.5S.772.CN Cc 82 8.2 - 8.0 7.1 FFA.5S.782.CN o Cc 92 9.2 - 9.0 8.1 FFA.5S.792.CN o c 10 10.2 - 10.0 9.1 FFA.5S.710.CN e Cc 11 11.2 - 11.0 10.1 FFA.5S.711.CN e Cc 12 12.2 - 12.0 11.1 FFA.5S.712.CN e c 13 13.2 - 13.0 12.1 FFA.5S.713.CN e Cc 14 14.2 - 14.0 13.1 FFA.5S.714.CN Cc 15 15.2 - 15.0 14.1 FFA.5S.715.CN Cc 16 16.2 - 16.0 15.1 FFA.5S.716.CN e Cc 17 17.2 - 17.0 16.1 FFA.5S.717.CN e Cc 18 18.2 - 18.0 17.1 FFA.58.718.CN e Cc 19 19.2 - 19.0 18.1 FFA.5S.719.CN @ Cc 20 20.2 19.7 20.0 19.1 FFA.5S.720.CN c 21 21.2 19.7 21.0 20.1 FFA.5S.721.CN o Cc 22 22.2 19.7 22.0 21.1 FFA.5S.722.CN @ K 23 23.2 - 23.0 22.1 FFA.6S.723.CN o FFA.5S.137.LCN FFA.6S.130.LC K 24 24.2 - 24.0 23.1 FFA.6S.724.CN o FFA.5S.137.LCN FFA.6S.130.LC K 25 25.2 - 25.0 24.1 FFA.6S.725.CN cS FFA.5S.137.LCON FFA.6S.130.LC K 26 5S 26.2 - 26.0 25.1 FFA.6S.726.CN e FFA.5S.137.LCN FFA.6S.130.LC K 27 27.2 - 27.0 26.1 FFA.6S.727.CN o FFA.5S.137.LCN FFA.6S.130.LC K 28 28.2 27.2 28.0 27.1 FFA.6S.728.CN a FFA.5S.137,.LCN FFA.6S.130.LC K 29 29.2 27.2 29.0 28.1 FFA.6S.729.CN S FFA.5S.137.LCN FFA.6S.130.LC K 30 30.2 27.2 30.0 29.1 FFA.6S.730.CN e FFA.5S.137.LON FFA.6S.130.LC Cc 72 7.2 - 7.0 6.1 FLA.5S.772.CN 1) Cc 82 8.2 - 8.0 7.1 FLA.5S.782.CN O1) Cc 92 9.2 - 9.0 8.1 FLA.5S.792.CN O11) c 10 10.2 - 10.0 9.1 FLA.5S.710.CN @1) Cc 11 11.2 - 11.0 10.1 FLA.5S.711.CN @ 1) Cc 12 12.2 - 12.0 11.1 FLA.5S.712.CN @1) c 13 13.2 - 13.0 12.4 FLA.5S.713.CN @1) c 14 14.2 - 14.0 13.1 FLA.5S.714.CN @1) Cc 15 15.2 - 15.0 14.1 FLA.5S.715.CN @1) Cc 16 16.2 - 16.0 15.1 FLA.5S.716.CN @1) c 17 17.2 - 17.0 16.1 FLA.58.717.CN @ 1) Cc 18 18.2 - 18.0 17.1 FLA.5S.718.CN @1) Cc 19 19.2 - 19.0 18.1 FLA.5S.719.CN @1) Cc 20 20.2 19.7 20.0 19.1 FLA.5S.720.CN @1) Cc 21 21.2 19.7 21.0 20.1 FLA.5S.721.CN ON Cc 22 22.2 19.7 22.0 21.1 FLA.5S.722.CN @1) C = Shielded S Series Collet K = Oversized S Series Collet requiring the use of an oversized collet and nut. 1) These can be used with models FLA, FFP, PCP @ Available Special order 82 ue L: LEME ELECTRONIC GOKINECTORS PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 meS Series ColletScontinuea Part Number 7 Ae / QED? Collet @ Cable @ Reference (mm) (mm) Collet Part Series Number Note Type @ SQA @B max. min. (If ordered separately) Cc 12 12.2 - 12.0 11.1 FFA.6S.712.CN Oo Cc 13 13.2 - 13.0 12.1 FFA.6S.713.CN OQ Cc 14 14.2 - 14.0 13.1 FFA.6S.714.CN O Cc 15 15.2 - 15.0 141 FFA.68.715.CN Co Cc 16 16.2 - 16.0 15.1 FFA.6S.716.CN Cc 17 17.2 - 17.0 16.1 FFA.6S.717.CN Oo Cc 18 18.2 - 18.0 17.1 FFA.6S.718.CN Cc Cc 19 19.2 - 19.0 18.1 FFA.6S.719.CN e@ Cc 20 20.2 - 20.0 19.1 FFA.6S.720.CN O Cc 21 6S 21.2 - 21.0 20.1 FFA.6S.721.CN C Cc 22 22.2 - 22.0 21.1 FFA.6S.722.CN OQ c 23 23.2 - 23.0 22.1 FFA.6S.723.CN oO c 24 24.2 - 24.0 23.1 FFA.6S.724.CN c c 25 25.2 - 25.0 24.1 FFA.6S.725.CN c c 26 26.2 - 26.0 25.1 FFA.6S.726.CN e c 27 27.2 - 27.0 26.1 FFA.6S.727.CN Cc c 28 28.2 27.2 28.0 27.1 FFA.6S.728.CN o Cc 29 29.2 27.2 29.0 28.1 FFA.6S.729.CN o c 30 30.2 27.2 30.0 29.1 FFA.6S.730.CN e C = Shielded S Series Collet K = Oversized S Series Collet requiring the use of an oversized collet and nut. @ Available Special order PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 L LEME BIG ELECTRONIC CONNECTORS 83S SeriesAssembly Instructions 1. Strip cable jacket as shown. 2. Slide collet nut and collet onto cable. If connector shell is to be grounded, fray shielding as shown. 3. Strip conductor insulation to dimension as shown below. 4. Position midpiece on insert as shown. (If split midpieces are used, terminate contacts before positioning midpieces.) . Terminate contacts using solder method. . Position collet as shown. . Fold and trim shielding over collet flange. . Install outershell and tighten collet nut to specified torque value as shown. FS EE emai way) gm jh. . ce NO Cable & Conductor Stripping Dimensions Single Contact Dimensions (mm) Size = (EC 00 3 6 AY : 0 4 9 1 5 13 2 6 17 3 7 20 4 10 22 Coaxial Size Dimensions (mm) 2 A B oT 00 4 9 0 5 11 1 7 15 2 7 19 3 8 22 4 10 27 5 10 42 Triaxial be Si Dimensions (mm) Ti Ize A|B;C/|DIE 11.0] 65 | 55 | 45 | 35 12.5| 70 | 55/45 |35 16.5| 9.0 | 7.5 | 60 | 4.0 21.0| 12.0] 10.0| 8.0 | 60 23.0 | 13.0] 11.0 | 9.0 | 7.0 Al[O/m/-/oO Multicontact (shielded cable) Dimensions (mm) Size A 5 oa oT its 0 3 7 c 1 3 10 2 4 13 3 4 16 4 4 18 5 4 29 6 4 31 DL LMI pc ELECTRONIC CONNECTORS 84 PO. Box 11488, Santa Rosa, CA 95406 (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869S Series Panel Cutouts and Torquing Shell Style __||_ Type (see below) | [Shell Style | Type (see below) | EBC P5 ERY P1 EBD P5 EWB P3 EBS PS FAA = EMP P4 HGP P3 ERA PY HGW PI [|___ShellStyle__|[_Type(seebelow) | [Shell Style || Type (see below) ERC Pt PSA PI ERD Pt PSP Pt ERM PI RAD Pt ERN PI SWH P4 ERT P2 GRA?) P6 Maximum Torquing Double Panel Washer Value of Receptacle Mounting Mounting Nuts Series Dimensions (mm) " Torque SAT H]L Series (\n.-lbs.) os 11 | 14 | 14 00 18 in.-ibs. 1S 14 | 20 | 17 os 25 in.-lbs. 1S 40 in.-Ibs. 2S 60 in.-Ibs. 38 100 in.-Ibs. 48 150 in.-Ibs. 58 220 in.-lbs. . . 6S 290 in.-Ibs. Maximum Torquing Value of Collet Nut | Series || Maximum Torque Wrench Part # 00 2 in.-Ibs. MTZ.00.517USA oS 4 in.-lbs. MTZ.0S.035.USA 1S 7 in.-Ibs. MTZ.18.062.USA 2s 11 in.-lbs. MTZ.28.101.USA 3S 15 in.-Ibs. MTZ.3S.163.USA Panel Hole Cutout Dimensions (Types) Dimensions (mm) For Mounting with Series Type P1 Type P2 Type P3 Type P4 Type P5 Type P6 Insulating Washer Al B{[t [aaj] et [eal ec [oat ct [oat Hy] et [eal Bs Dimensions 00 74] 641116} 600] 10 | - - - ~ - - - | 90] 82 Size (mm) os 91] 83) 136) - - | 124 | 170 | 101] 150] - - - | 110 | 101 @Al| B is || 121 | 106 | 170 | 1198] 17 | 141 | 205 | 121] 170 | 11.4 | 12.4] 19 | 14.0 | 12.4 0 10.9 | 10.0 2s 1454] 136] ais} - | - | 161 | 225] 151] 215 | 151] 155] 23 | 180] 164 1 13.9 | 12.3 3s_ lf 182] 166] 270) - | - | 202] 285/182] 270] - | 180] 26 | 220 | 204 2 17.9 | 16.3 4s || 252|236|340| - | - |252]340]252]340/ - | - | - | 290] 274 3 22.0 | 20.4 58 |[a52|/336l440] - | - | 352] 4207352] 420] - | 368] 47 | 392] 374 4 29.0 | 27.4 6s |j/4a3|456/580| - | - | - | - |aas{sso] - | - | - | - [ - 5 - | - L LEM | ELECTRONIC CONNECTORS: PO. Box 11488, Santa Rosa, CA 95406 * (800) 444-LEMO (5366) (707) 578-8811 telefax 707/578-0869 85