1
Rectifier Device Data
Dual Schottky Rectifier
...using Schottky Barrier technology with a platinum barrier metal. This
state–of–the–art device is designed for use in high frequency switching power
supplies and converters with up to 48 volt outputs. They block up to 200 volts and
offer improved Schottky performance at frequencies from 250 kHz to 5.0 MHz.
•200 Volt Blocking Voltage
•Low Forward Voltage Drop
•Guardring for Stress Protection and High dv/dt Capability
(10,000 V/µs)
•Dual Diode Construction — Terminals 1 and 3 Must be
Connected for Parallel Operation at Full Rating
Mechanical Characteristics
•Case: Epoxy, Molded
•Weight: 1.9 grams (approximately)
•Finish: All External Surfaces Corrosion Resistant and Terminal
Leads are Readily Solderable
•Lead Temperature for Soldering Purposes: 260°C Max. for 10
Seconds
•Shipped 50 units per plastic tube
•Marking: B20200
MAXIMUM RATINGS (PER LEG)
Rating Symbol Value Unit
Peak Repetitive Reverse Voltage
Working Peak Reverse Voltage
DC Blocking Voltage
VRRM
VRWM
VR
200 Volts
Average Rectified Forward Current Per Leg
(Rated VR) TC = 125°C Per Package IF(AV) 10
20 Amps
Peak Repetitive Forward Current, Per Leg
(Rated VR, Square Wave, 20 kHz) TC = 90°CIFRM 20 Amps
Nonrepetitive Peak Surge Current
(Surge applied at rated load conditions halfwave, single phase, 60 Hz) IFSM 150 Amps
Peak Repetitive Reverse Surge Current (2.0 µs, 1.0 kHz) IRRM 1.0 Amp
Operating Junction Temperature TJ–65 to +150 °C
Storage Temperature Tstg –65 to +175 °C
Voltage Rate of Change (Rated VR) dv/dt 10,000 V/µs
THERMAL CHARACTERISTICS (PER LEG)
Thermal Resistance — Junction to Case RθJC 2.0 °C/W
ELECTRICAL CHARACTERISTICS (PER LEG)
Maximum Instantaneous Forward Voltage (1) (IF = 10 Amps, TC = 25°C)
(IF = 10 Amps, TC = 125°C)
(IF = 20 Amps, TC = 25°C)
(IF = 20 Amps, TC = 125°C)
VF0.9
0.8
1.0
0.9
Volts
Maximum Instantaneous Reverse Current (1) (Rated dc Voltage, TC = 25°C)
(Rated dc Voltage, TC = 125°C) IR1.0
50 mA
DYNAMIC CHARACTERISTICS (PER LEG)
Capacitance (VR = –5.0 V, TC = 25°C, Frequency = 1.0 MHz) CT500 pF
(1) Pulse Test: Pulse Width = 300 µs, Duty Cycle ≤2.0%.
SWITCHMODE is a trademark of Motorola, Inc.
Motorola, Inc. 1996
Order this document
by MBR20200CT/D
SEMICONDUCTOR TECHNICAL DATA
1
3
2, 4
SCHOTTKY BARRIER
RECTIFIER
20 AMPERES
200 VOLTS
CASE 221A–06
(TO–220AB)
1
3
4
2
Rev 1
MBR20200CT
2Rectifier Device Data
Figure 1. Typical Forward Voltage (Per Leg)
100
70
50
20
10
7
5
2
10.2 0.4 0.6 0.8 1
TJ = 125
°
C
TJ = 100
°
C
TJ = 25
°
C
vF, INSTANTANEOUS VOLTAGE (VOLTS)
TJ = 150
°
C
I , INSTANEOUS FORWARD CURRENT (AMP)
F
I , REVERSE CURRENT ( A)
R
µ
VR, REVERSE CURRENT (VOLTS)
10,000
1,000
100
10
1
0.1
0.01 20 40 60 80 100 120 140 160 180 200
TJ = 125
°
C
TJ = 100
°
C
TJ = 150
°
C
TJ = 25
°
C
Figure 2. Typical Reverse Current (Per Leg)
0
40
36
32
28
24
20
16
12
8
4
00 5 10 15 20 25 30 35
TJ = 125
°
C
10
dc
SQUARE
WAVE
IPK
IAV = 20
IF(AV), A VERAGE FORWARD CURRENT (AMPS)
Figure 3. Forward Power Dissipation
P , AVERAGE POWER DISSIPATION (WATTS)
F(AV)
25
20
15
10
5
090 100 110 120 130 140 150 160
I , AVERAGE FORWARD CURRENT (AMPS)
F(AV)
TC, CASE TEMPERATURE (
°
C)
Figure 4. Current Derating, Case
SQUARE
WAVE dc
RATED VOLTAGE
R
θ
JC = 2
°
C/W
I , AVERAGE FORWARD CURRENT (AMPS)
F(AV)
R
θ
JA = 16
°
C/W
RATED VOLT AGE
20
16
12
8
4
0
TA, AMBIENT TEMPERATURE (
°
C)
Figure 5. Current Derating, Ambient
dc
SQUARE
WAVE
0 25 50 75 100 125 150 175
500
400
300
200
100
0
C, CAPACITANCE (pF)
TJ = 25
°
C
VR, REVERSE VOLTAGE (VOL TS)
1 2 5 10 20 50 70 100
Figure 6. Typical Capacitance (Per Leg)
MBR20200CT
3
Rectifier Device Data
PACKAGE DIMENSIONS
CASE 221A–06
(TO–220AB)
NOTES:
1. DIMENSIONING AND TOLERANCING PER ANSI
Y14.5M, 1982.
2. CONTROLLING DIMENSION: INCH.
3. DIMENSION Z DEFINES A ZONE WHERE ALL
BODY AND LEAD IRREGULARITIES ARE
ALLOWED.
DIM MIN MAX MIN MAX
MILLIMETERSINCHES
A0.570 0.620 14.48 15.75
B0.380 0.405 9.66 10.28
C0.160 0.190 4.07 4.82
D0.025 0.035 0.64 0.88
F0.142 0.147 3.61 3.73
G0.095 0.105 2.42 2.66
H0.110 0.155 2.80 3.93
J0.018 0.025 0.46 0.64
K0.500 0.562 12.70 14.27
L0.045 0.060 1.15 1.52
N0.190 0.210 4.83 5.33
Q0.100 0.120 2.54 3.04
R0.080 0.110 2.04 2.79
S0.045 0.055 1.15 1.39
T0.235 0.255 5.97 6.47
U0.000 0.050 0.00 1.27
V0.045 ––– 1.15 –––
Z––– 0.080 ––– 2.04
B
Q
H
Z
L
V
G
N
A
K
F
123
4
D
SEATING
PLANE
–T–
C
S
T
U
R
J
ISSUE Y
STYLE 6:
PIN 1. ANODE
2. CATHODE
3. ANODE
4. CATHODE
MBR20200CT
4Rectifier Device Data
Motorola reserves the right to make changes without further notice to any products herein. Motorola makes no warranty, representation or guarantee regarding
the suitability of its products for any particular purpose, nor does Motorola assume any liability arising out of the application or use of any product or circuit, and
specifically disclaims any and all liability, including without limitation consequential or incidental damages. “Typical” parameters which may be provided in Motorola
data sheets and/or specifications can and do vary in different applications and actual performance may vary over time. All operating parameters, including “Typicals”
must be validated for each customer application by customer’s technical experts. Motorola does not convey any license under its patent rights nor the rights of
others. Motorola products are not designed, intended, or authorized for use as components in systems intended for surgical implant into the body, or other
applications intended to support or sustain life, or for any other application in which the failure of the Motorola product could create a situation where personal injury
or death may occur. Should Buyer purchase or use Motorola products for any such unintended or unauthorized application, Buyer shall indemnify and hold Motorola
and its officers, employees, subsidiaries, affiliates, and distributors harmless against all claims, costs, damages, and expenses, and reasonable attorney fees
arising out of, directly or indirectly, any claim of personal injury or death associated with such unintended or unauthorized use, even if such claim alleges that
Motorola was negligent regarding the design or manufacture of the part. Motorola and are registered trademarks of Motorola, Inc. Motorola, Inc. is an Equal
Opportunity/Af firmative Action Employer.
Mfax is a trademark of Motorola, Inc.
How to reach us:
USA/EUROPE/Locations Not Listed: Motorola Literature Distribution; JAPAN: Nippon Motorola Ltd.; Tatsumi–SPD–JLDC, 6F Seibu–Butsuryu–Center,
P.O. Box 5405, Denver , Colorado 80217. 303–675–2140 or 1–800–441–2447 3–14–2 Tatsumi Koto–Ku, Tokyo 135, Japan. 81–3–3521–8315
Mfax: RMF AX0@email.sps.mot.com – TOUCHT ONE 602–244–6609 ASIA/PACIFIC: Motorola Semiconductors H.K. Ltd.; 8B Tai Ping Industrial Park,
INTERNET: http://Design–NET.com 51 Ting K o k Road, Tai Po, N.T., Hong Kong. 852–26629298
MBR20200CT/D
◊
